Quincy Air Compressor QSI Parts Manual 2012203883

Professional Air Compressor Replacement Parts Service Provider

+1 (707)-800-9555 (Phone & WhatsApp)

info@filmecompressor.com

filmecompressor@gmail.com

 

Quincy Air Compressor QSI Parts Manual 2012-2038-83
QSI-220i/245i
QSI-250i/300i
Direct Drive Industrial Air Compressor
Parts Manual
This manual contains important safety information and should be made available to 
all personnel who operate and/or maintain this product. Carefully read this manual 
before attempting to operate or perform maintenance on this equipment.
Manual No. 2012203883
June 2017 Edition

 
• Fluid Requirements
QSI 220i/245i - 14 gallons
 QSI 250i/300i - 14 gallons
 HORSEPOWER COOLING PSI
QSI 50 60 A/C 100 125 150
6  - QSI 245i/300i
 
Recommended Spare Parts
 QTY. PART NUMBER DESCRIPTION
 1 2011020135 SHAFT SEAL KIT
 1 2014706101 SWITCH,TMP,230F 230-242,0,SPST
 1 1627456261 DIFFERENTIAL PILOT VALVE KIT
 (INCLUDES DIAPHRAGM ASSEMBLY & SEAT)
 1 2013400360 AIR FILTER ELEMENT
 1 2013402056 AIR/FLUID SEPARATOR
 1 1627456072 MINIMUM PRESSURE CHECK VALVE KIT
 1 2013400282 FLUID FILTER ELEMENT
 1 1627456034 THERMAL VALVE KIT 
 (INCLUDES ELEMENT, SEAL & O-RING)
 3 1627456169 QUINSYN-PG FLUID (5 GALLON CONTAINER)
 3 1627456172 QUINSYN-PLUS FLUID (5 GALLON CONTAINER)
 3 1627456002 QUINSYN-F FLUID (5 GALLON CONTAINER)
 3 2013100306 QUINSYN-XP FLUID (5 GALLON CONTAINER)
 - QSI 245i/300i 7
Airend (less lift valves, less fluid pump) - 2012200583
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2014500404 COMPRESSOR FLUID SLINGER
20 1 2014500380 SEAL ADAPTER
30 4 2014700317 COUNTERBORE SCREW-1/4-20 UNC X 1.50,
 GRADE 8 (@ 9 FT-LBS )
40 1 2014700603 VITON O-RING -3.75 I.D.
50 1 1627413033 S HAFT SEAL
60 1 1627413032 WEARRING SEAL
70 * 2014300304 INLET CASING
80 11 2014705350 PIPE PLUG-7/16-20 (O-RING)
90 2 2014704487 DOWEL PIN
100 1 2014700607 VITON O-RING -14.00 I.D.
 1 2014700608 VITON O-RING -16.00 I.D.
 (245I/50 HZ, 250I & 300I/60HZ, 300I/50 HZ/150#)
110 * 2014300673 ROTOR HOUSING
120 * 2014500065 ROTOR BEARING
130 * 2014704265 BEARING
140 * 2014300645 MALE ROTOR -204 MM
8  - QSI 245i/300i
Airend (less lift valves, less fluid pump) - 2012200583
ITEM NO. QTY. PART NUMBER DESCRIPTION
150 * 2014300648 FEMALE ROTOR -204 MM
160 1 1627450257 PLUG ORIFIC E-0.12 NPT
170 9 2014700064 COUNTERBORE SCR EW-1/2-13 UNC X 2.00,
 GRADE 8 (@ 75 FT-LBS )
180 1 2025501276 CAP SCREW-1/2-13 UNC X 1.75, GRADE 5 (@ 55 FT-LBS )
190 1 2014502673 FLUID GA LLERY PLAT E GASKET
 1 2014502726 FLUID GA LLERY PLAT E GASKET
 (245I/50 HZ, 250I & 300I, 300I/50 HZ/150#)
200 1 2014502671 FLUID GA LLERY CO VER PLAT E
 1 2014502725 FLUID GA LLERY CO VER PLAT E
 (245I/50 HZ, 250I & 300I, 300I/50 HZ/150#)
210 8 2025501423 COUNTERBORE SCREW-3/8-16 UNC X 1.00,
 GRAD E 8 (@ 35 FT-LBS )
220 * 2014500067 ROTOR BEARING
230 1 2014704280 BEARING RETAIN ER RING
240 * 2014500524 ROTOR BEARING
250 * 2014500531 ROTOR BEARING
260 * 2014500530 ROTOR BEARING
270 16 2014501488 COMPR ESSION SPRING
280 2 2014501450 BEARING RETAINER
290 6 2014700291 COUNT ERBORE SCREW-3/8-16 UNC X 1.25,
 GRAD E 8 (@ 45 FT-LBS , BACK OFF TO 25 FT-LBS )
300 1 2014700558 VITON O-RING -4.38 I.D.
310 1 2014300668 DISC HARG E END CAP
320 ** 2014500846 ROTOR SHIM -TEMP ERED ST EEL/BRASS
330 ** 2014500580 ROTOR SHIM -TEMP ERED ST EEL/BRASS
340 1 2014700641 VITON O-RING -5.25 I.D.
350 1 2014300670 DISC HARG E END CAP
360 8 2014700299 COUNTERBORE SCREW-1/2-13 UNC X 1.50,
 GRAD E 8 (@ 75 FT-LBS )
370 3 2010356525 PIPE PLUG-3/4-16 (O-RING)
380 1 2014701185 45° MALE ELBO W-0.25 TUBE X 0.12 NPT
390*** 2 2013200489 PLUG ORIFICE-0.125 NPT
 3 2013200486 PLUG ORIFICE-0.125 NPT (250I & 300I/50HZ)
400*** 1 2013200488 PLUG ORIFICE-0.25 NPT
410 1 2014701277 PIPE PLUG-0.125 NPT (250I & 300I/50HZ ONLY)
420**** 1 1627413044 INLET VALVE GASKET
430**** 1 2014600095 INLETVALVE ADAPTER PLATE
440**** 4 2025501274 CAP SCREW-1/2-13 UNC X 1.25, GRADE 5 (@ 55 FT-LBS )
COMPONENT MAINTENANCE PARTS
A 11 2010356518 VITON O-RING -0.35 I.D.
B 3 2010356498 VITON O-RING -0.64 I.D.
 * ITEMS NOT SOLD SEPARATELY, MUST BE ORDERED AS A COMPLETE AIREND.
 ** QUANTITY AS REQUIRED.
 *** NOT USED ON QSI-245I/50 HZ, QSI-250I/-300I/60 HZ OR QSI-300I/50 HZ/150# UNITS.
 **** USED ONLY ON QSI-300I/50 HZ/150# UNITS.

Shaft Seal Kit - 1627413038
ITEM NO. QTY. PART NUMBER DESCRIPTION
 1 1 2014500404 COMPRESSOR
 FLUID SLINGER
 2 1 1627413033 SHAFT SEAL
 3 1 1627413032 WEAR RING SEAL
REFERENCE QSI INSTRUCTION MANUAL TO INSTALL COMPRESSOR
SHAFT SEAL. TOOL KIT 140284 FOR QSI SHAFT SEAL AND WEAR
RING INSTALLATION CAN BE PURCHASED FROM QUINCY COMPRESSOR.
 - QSI 245i/300i 9
Airend (less lift valves, with fluid pump (male pump drive)) - 2012200575
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2014500404 COMPR ESSOR FLUID SLINGER
20 1 2014500380 SEAL ADAPTER
30 4 2014700317 COUNTERBORE SCREW-1/4-20 UNC X 1.50,
 GRADE 8 (@ 9 FT-LBS)
40 1 2014700603 VITON O-RING-3.75 I.D.
50 1 1627413033 SHAFT SEAL
60 1 1627413032 WEAR RING SEAL
70 * 2014300304 INLET CASING
80 11 2014705350 PIPE PLUG-7/16-20 (O-RING)
90 2 2014704487 DOWEL PIN
100 1 2014700607 VITON O-RING-14.00 I.D.
 1 2014700608 VITON O-RING-16.00 I.D.
110 * 2014300673 ROTOR HOUSING
120 * 2014500065 ROTOR BEARING
130 * 2014704265 BEARING
140 * 2014300645 MALE ROTOR-204 MM
150 * 2014300648 FEMALE ROTOR-204 MM
160 1 1627450257 PLUG ORIFICE-0.12 NPT
10  - QSI 245i/300i
Airend (less lift valves, with fluid pump (male pump drive)) - 2012200575
ITEM NO. QTY. PART NUMBER DESCRIPTION
170 9 2014700064 COUNTERBORE SCREW-1/2-13 UNC X 2.00,
 GRADE 8 (@ 75 FT-LBS)
180 1 2025501276 CAP SCREW-1/2-13 UNC X 1.75, GRADE 5 (@ 55 FT-LBS)
190 1 2014502673 FLUID GALLERY PLATE GASKET
 1 2014502726 FLUID GALLERY PLATE GASKET
 (245I/50 HZ, 250I & 300I, 300I/50 HZ/150#)
200 1 2014502726 FLUID GALLERY COVER PLATE
 1 2010352529 FLUID GALLERY COVER PLATE
 (245I/50 HZ, 250I & 300I, 300I/50 HZ/150#)
210 8 2025501423 COUNTERBORE SCREW-3/8-16 UNC X 1.00,
 GRADE 8 (@ 35 FT-LBS)
220 * 2014500067 ROTOR BEARING
230 1 2014704280 BEARING RETAINER RING
240 * 2014500524 ROTOR BEARING
250 * 2014500531 ROTOR BEARING
260 * 2014500530 ROTOR BEARING
270 16 2014501488 COMPRESSION SPRING
280 1 2014501450 BEARING RETAINER
290 3 2014700291 COUNTERBORE SCREW-3/8-16 UNC X 1.25,
 GRADE 8 (@ 45 FT-LBS, BACK OFF TO 25 FT-LBS)
300 1 2014700558 VITON O-RING-4.38 I.D.
310 1 2014300668 DISCHARGE END CAP
320 ** 2014500846 ROTOR SHIM-TEMPERED STEEL/BRASS
330 ** 2014500580 ROTOR SHIM-TEMPERED STEEL/BRASS
340 1 2014500840 BEARING RETAINER
350 3 2014700293 COUNTERBORE SCREW-3/8-16 UNC X 2.25,
 GRADE 8 (@ 45 FT-LBS, BACK OFF TO 25 FT-LBS)
360 1 2014700641 VITON O-RING-5.25 I.D.
370 1 2014501447 FLUID PUMP ADAPTER
380 8 2014700299 COUNTERBORE SCREW-1/2-13 UNC X 1.50,
 GRADE 8 (@ 75 FT-LBS)
390 1 2014502674 FLUID PUMP GASKET
400 1 2014500123 COMPRESSOR FLUID PUMP
410 3 2010356525 PIPE PLUG-3/4-16 (O-RING)
420 1 2014701185 45° MALE ELBOW-0.25 TUBE X 0.12 NPT
430*** 2 2013200489 PLUG ORIFICE-0.125 NPT
440*** 1 2013200488 PLUG ORIFICE-0.25 NPT
COMPONENT MAINTENANCE PARTS
 A 11 2010356518 VITON O-RING-0.35 I.D.
 B 3 2010356498 VITON O-RING-0.64 I.D.
 * ITEMS NOT SOLD SEPARATELY, MUST BE ORDERED AS A COMPLETE AIREND.
 ** QUANTITY AS REQUIRED.
 *** NOT USED ON QSI-245I/50 HZ, 250I/300I/60 HZ OR 300I/50 HZ/150# UNITS.

Shaft Seal Kit - 1627413038
ITEM NO. QTY. PART NUMBER DESCRIPTION
 1 1 2014500404 COMPRESSOR
 FLUID SLINGER
 2 1 1627413033 SHAFT SEAL
 3 1 1627413032 WEAR RING SEAL
REFERENCE QSI INSTRUCTION MANUAL TO INSTALL COMPRESSOR
SHAFT SEAL. TOOL KIT 140284 FOR QSI SHAFT SEAL AND WEAR
RING INSTALLATION CAN BE PURCHASED FROM QUINCY COMPRESSOR.
 - QSI 245i/300i 11
Airend (less lift valves, with fluid pump (female pump drive)) - 
2012200595
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2014500404 COMPRESSOR FLUID SLINGER
20 1 2014500380 SEAL ADAPTER
30 4 2014700317 COUNTERBORE SCREW-1/4-20 UNC X 1.50,
 GRADE 8 (@ 9 FT-LBS)
40 1 2014700603 VITON O-RING-3.75 I.D.
50 1 1627413033 SHAFT SEAL
60 1 1627413032 WEAR RING SEAL
70 * 2014300304 INLET CASING
80 11 2014705350 PIPE PLUG-7/16-20 (O-RING)
90 2 2014704487 DOWEL PIN
100 1 2014700607 VITON O-RING-14.00 I.D.
110 * 2014300696 ROTOR HOUSING
120 * 2014500065 ROTOR BEARING
130 * 2014704265 BEARING
140 * 2014300658 MALE ROTOR-204 MM
150 * 2014300660 FEMALE ROTOR-204 MM
160 1 1627450257 PLUG ORIFICE-0.12 NPT
12  - QSI 245i/300i
Airend (less lift valves, with fluid pump (female pump drive)) - 
2012200595
ITEM NO. QTY. PART NUMBER DESCRIPTION
170 10 2014700064 COUNTERBORE SCREW-1/2-13 UNC X 2.00,
 GRADE 8 (@ 75 FT-LBS)
180 1 2014502726 FLUID GALLERY PLATE GASKET
190 1 2014502725 FLUID GALLERY COVER PLATE
200 10 2025501423 COUNTERBORE SCREW-3/8-16 UNC X 1.00,
 GRADE 8 (@ 35 FT-LBS)
210 * 2014500067 ROTOR BEARING
220 1 2014704280 BEARING RETAINER RING
230 * 2014500524 ROTOR BEARING
240 * 2014500531 ROTOR BEARING
250 * 2014500530 ROTOR BEARING
260 16 2014501488 COMPRESSION SPRING
270 1 2014500858 BEARING RETAINER
280 3 2014700296 CUNTERBORE SCREW-3/8-16 UNC X 3.00,
 GRADE 8 (@ 45 FT-LBS, BACK OFF TO 25 FT-LBS)
290 1 2014700558 VITON O-RING-4.38 I.D.
300 1 2014501448 FLUID PUMP ADAPTER
310 ** 2014500846 ROTOR SHIM-TEMPERED STEEL/BRASS
320 ** 2014500580 ROTOR SHIM-TEMPERED STEEL/BRASS
330 1 2014501450 BEARING RETAINER
340 3 2014700291 COUNTERBORE SCREW-3/8-16 UNC X 1.25,
 GRADE 8 (@ 45 FT-LBS, BACK OFF TO 25 FT-LBS)
350 1 2014700641 VITON O-RING-5.25 I.D.
360 1 2014300670 DISCHARGE END CAP
370 8 2014700299 COUNTERBORE SCREW-1/2-13 UNC X 1.50,
 GRADE 8 (@ 75 FT-LBS)
380 1 2014502674 FLUID PUMP GASKET
390 1 2014500124 COMPRESSOR FLUID PUMP
400 3 2010356525 PIPE PLUG-3/4-16 (O-RING)
410 1 2014701185 45° MALE ELBOW-0.25 TUBE X 0.12 NPT
420 3 2013200486 PLUG ORIFICE-0.125 NPT
430 1 2013200488 PLUG ORIFICE-0.25 NPT
440 1 2014701277 PIPE PLUG-0.125 NPT
COMPONENT MAINTENANCE PARTS
 A 11 2010356518 VITON O-RING-0.35 I.D.
 B 3 2010356498 VITON O-RING-0.64 I.D.
 * ITEMS NOT SOLD SEPARATELY, MUST BE ORDERED AS A COMPLETE AIREND.
 ** QUANTITY AS REQUIRED.
 *** THIS CONFIGURATION (FEMALE PUMP DRIVE) IS USED ONLY ON QSI-250I/50 HZ & 300I/50 HZ.

Shaft Seal Kit - 1627413038
ITEM NO. QTY. PART NUMBER DESCRIPTION
 1 1 2014500404 COMPRESSOR
 FLUID SLINGER
 2 1 1627413033 SHAFT SEAL
 3 1 1627413032 WEAR RING SEAL
REFERENCE QSI INSTRUCTION MANUAL TO INSTALL COMPRESSOR
SHAFT SEAL. TOOL KIT 140284 FOR QSI SHAFT SEAL AND WEAR
RING INSTALLATION CAN BE PURCHASED FROM QUINCY COMPRESSOR.
 - QSI 245i/300i 13
Airend (with lift valves, less fluid pump) - 2012200753
Shaft Seal Kit - 1627413038
ITEM NO. QTY. PART NUMBER DESCRIPTION
 1 1 2014500404 COMPRESSOR
 FLUID SLINGER
 2 1 1627413033 SHAFT SEAL
 3 1 1627413032 WEAR RING SEAL
REFERENCE QSI INSTRUCTION MANUAL TO INSTALL COMPRESSOR
SHAFT SEAL. TOOL KIT 140284 FOR QSI SHAFT SEAL AND WEAR
RING INSTALLATION CAN BE PURCHASED FROM QUINCY COMPRESSOR.
14  - QSI 245i/300i
Airend (with lift valves, less fluid pump) - 2012200753
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2014500404 COMPRESSOR FLUID SLINGER
20 1 2014500380 SEAL ADAPTER
30 4 2014700317 COUNTERBORE SCREW-1/4-20 UNC X 1.50,
 GRADE 8 (@ 9 FT-LBS)
40 1 2014700603 VITON O-RING-3.75 I.D.
50 1 1627413033 SHAFT SEAL
60 1 1627413032 WEAR RING SEAL
70 * 2014300543 INLET CASING
80 12 2014705350 PIPE PLUG-7/16-20 (O-RING)
90 2 2014704487 DOWEL PIN
100 1 2014700608 VITON O-RING-16.00 I.D.
110 * 2014300677 ROTOR HOUSING
120 * 2014500065 ROTOR BEARING
130 * 2014704265 BEARING
140 * 2014300645 MALE ROTOR-204 MM
150 * 2014300647 FEMALE ROTOR-204 MM
160 1 1627450257 PLUG ORIFICE-0.12 NPT
170 9 2014700064 COUNTERBORE SCREW-1/2-13 UNC X 2.00,
 GRADE 8 (@ 75 FT-LBS)
180 1 2025501276 CAP SCREW-1/2-13 UNC X 1.75, GRADE 5 (@ 55 FT-LBS)
190 1 2014502673 FLUID GALLERY PLATE GASKET
 1 2014502726 FLUID GALLERY PLATE GASKET
 (245I/50 HZ, 250I & 300I, 300I/50 HZ/150#)
200 1 2014502671 FLUID GALLERY COVER PLATE
 1 2014502725 FLUID GA LLERY CO VER PLATE
 (245I/50 HZ, 250I & 300I, 300I/50 HZ/150#)
210 16 2025501423 COUNTERBORE SCREW-3/8-16 UNC X 1.00,
 GRADE 8 (@ 35 FT-LBS)
220 * 2014500067 ROTOR BEARING
230 1 2014704280 BEARING RETAINER RING
240 * 2014500524 ROTOR BEARING
250 * 2014500531 ROTOR BEARING
260 * 2014500530 ROTOR BEARING
270 16 2014501488 COMPR ESSION SPRING
280 2 2014501450 BEARING RETAINER
290 6 2014700291 COUNTERBORE SCREW-3/8-16 UNC X 1.25,
 GRADE 8 (@ 45 FT-LBS, BACK OFF TO 25 FT-LBS)
300 1 2014700558 VITON O-RING-4.38 I.D.
310 1 2014300668 DISCHARGE END CAP
320 ** 2014500846 ROTOR SHIM-TEMPERED STEEL/BRASS
330 ** 2014500580 ROTOR SHIM-TEMPERED STEEL/BRASS
340 1 2014700641 VITON O-RING-5.25 I.D.
350 1 2014300670 DISCHARGE END CAP
360 8 2014700299 COUNTERBORE SCREW-1/2-13 UNC X 1.50,
 GRADE 8 (@ 75 FT-LBS)
370 2 2010356525 PIPE PLUG-3/4-16 (O-RING)
380 1 2014701185 45° MALE ELBOW-0.25 TUBE X 0.12 NPT
390 1 2014100578 PATENT PLATE
400 2 2014704468 DATA PLATE PIN
410 4 2013900269 LIFT VALVE (INCLUDES O-RING 22749-141)
COMPONENT MAINTENANCE PARTS
 A 12 2010356518 VITON O-RING-0.35 I.D.
 B 2 2010356498 VITON O-RING-0.64 I.D.
 * ITEMS NOT SOLD SEPARATELY, MUST BE ORDERED AS A COMPLETE AIREND.
 ** QUANTITY AS REQUIRED.

 - QSI 245i/300i 15
Airend (with lift valves, with fluid pump (male pump drive)) - 
2012200584
Shaft Seal Kit - 1627413038
ITEM NO. QTY. PART NUMBER DESCRIPTION
 1 1 2014500404 COMPRESSOR
 FLUID SLINGER
 2 1 1627413033 SHAFT SEAL
 3 1 1627413032 WEAR RING SEAL
REFERENCE QSI INSTRUCTION MANUAL TO INSTALL COMPRESSOR
SHAFT SEAL. TOOL KIT 140284 FOR QSI SHAFT SEAL AND WEAR
RING INSTALLATION CAN BE PURCHASED FROM QUINCY COMPRESSOR.
16  - QSI 245i/300i
Airend (with lift valves, with fluid pump (male pump drive)) - 
2012200584
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2014500404 COMPRESSOR FLUID SLINGER
20 1 2014500380 SEAL ADAPTER
30 4 2014700317 COUNTERBORE SCREW-1/4-20 UNC X 1.50,
 GRADE 8 (@ 9 FT-LBS)
40 1 2014700603 VITON O-RING-3.75 I.D.
50 1 1627413033 SHAFT SEAL
60 1 1627413032 WEAR RING SEAL
70 * 2014300543 INLET CASING
80 12 2014705350 PIPE PLUG-7/16-20 (O-RING)
90 2 2014704487 DOWEL PIN
100 1 2014700608 VITON O-RING-16.00 I.D.
110 * 2014300677 ROTOR HOUSING
120 * 2014500065 ROTOR BEARING
130 * 2014704265 BEARING
140 * 2014300645 MALE ROTOR-204 MM
150 * 2014300647 FEMALE ROTOR-204 MM
160 1 2010352683 PLUG ORIFICE-0.12 NPT
170 9 2014700064 COUNTERBORE SCREW-1/2-13 UNC X 2.00,
 GRADE 8 (@ 75 FT-LBS)
180 1 2025501276 CAP SCREW-1/2-13 UNC X 1.75, GRADE 5 (@ 55 FT-LBS)
190 1 2014502673 FLUID GALLERY PLAT E GASK ET
 1 2014502726 FLUID GALLERY PLAT E GASK ET
 (245I/50 HZ, 250I & 300I, 300I/50 HZ/150#)
200 1 2014502671 FLUID GALLERY COVER PLATE
 1 2014502725 FLUID GALLERY COVER PLATE
 (245I/50 HZ, 250I & 300I, 300I/50 HZ/150#)
210 16 2025501423 COUNTERBORE SCREW-3/8-16 UNC X 1.00,
 GRADE 8 (@ 35 FT-LBS)
220 * 2014500067 ROTOR BEARING
230 1 2014704280 BEARING RETAINER RING
240 * 2014500524 ROTOR BEARING
250 * 2014500531 ROTOR BEARING
260 * 2014500530 ROTOR BEARING
270 16 2014501488 COMPRESSION SPRING
280 1 2014501450 BEARING RETAINER
290 3 2014700291 COUNTERBORE SCREW-3/8-16 UNC X 1.25,
 GRADE 8 (@ 45 FT-LBS, BACK OFF TO 25 FT-LBS)
300 1 2014700558 VITON O-RING-4.38 I.D.
310 1 2014300668 DISC HARGE END CAP
320 ** 2014500846 ROTOR SHIM-TEMPERED STEEL/BRASS
330 ** 2014500580 ROTOR SHIM-TEMPERED STEEL/BRASS
340 1 2014500840 BEARING RETAINER
350 3 2014700293 COUNTERBORE SCREW-3/8-16 UNC X 2.25,
 GRADE 8 (@ 45 FT-LBS, BACK OFF TO 25 FT-LBS)
360 1 2014700641 VITON O-RING-5.25 I.D.
370 1 2014501447 FLUID PUMP ADAPTER
380 8 2014700299 COUNTERBORE SCREW-1/2-13 UNC X 1.50,
 GRADE 8 (@ 75 FT-LBS)
390 1 2014502674 FLUID PUMP GASKET
400 1 2014500123 COMPRESSOR FLUID PUMP
410 2 2010356525 PIPE PLUG-3/4-16 (O-RING)
420 1 2014701185 45° MALE ELBOW-0.25 TUBE X 0.12 NPT
450 1 2014100578 PATENT PLATE
460 2 2014704468 DATA PLATE PIN
470 4 2013900269 LIFT VALVE (INCLUDES O-RING 22749-141)
 
COMPONENT MAINTENANCE PARTS
 A 11 140406-904 VITON O-RING-0.35 I.D.
 B 3 140406-908 VITON O-RING-0.64 I.D.
 * ITEMS NOT SOLD SEPARATELY, MUST BE ORDERED AS A COMPLETE AIREND.
 ** QUANTITY AS REQUIRED.

 - QSI 245i/300i 17
Airend (with lift valves, with fluid pump (female pump drive)) - 
2012200597
Shaft Seal Kit - 1627413038
ITEM NO. QTY. PART NUMBER DESCRIPTION
 1 1 2014500404 COMPRESSOR
 FLUID SLINGER
 2 1 1627413033 SHAFT SEAL
 3 1 1627413032 WEAR RING SEAL
REFERENCE QSI INSTRUCTION MANUAL TO INSTALL COMPRESSOR
SHAFT SEAL. TOOL KIT 140284 FOR QSI SHAFT SEAL AND WEAR
RING INSTALLATION CAN BE PURCHASED FROM QUINCY COMPRESSOR.
18  - QSI 245i/300i
Airend (with lift valves, with fluid pump (female pump drive)) - 
2012200597
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2014500404 COMPRESSOR FLUID SLINGER
20 1 2014500380 SEAL ADAPTER
30 4 2014700317 COUNTERBORE SCREW-1/4-20 UNC X 1.50,
 GRADE 8 (@ 9 FT-LBS)
40 1 2014700603 VITON O-RING-3.75 I.D.
50 1 1627413033 SHAFT SEAL
60 1 1627413032 WEAR RING SEAL
70 1 2014300543 INLET CASING
80 12 2014705350 PIPE PLUG-7/16-20 (O-RING)
90 2 2014704487 DOWEL PIN
100 1 2014700608 VITON O-RING-16.00 I.D.
110 1 2014300704 ROTOR HOUSING
120 2 2014500065 ROTOR BEARING
130 2 2014704265 BEARING
140 1 2014300658 MALE ROTOR-204 MM
150 1 2014300661 FEMALE ROTOR-204 MM
160 1 1627450257 PLUG ORIFICE-0.12 NPT
170 12 2014700064 COUNTERBORE SCREW-1/2-13 UNC X 2.00,
 GRADE 8 (@ 75 FT-LBS)
180 1 2014502726 FLUID GALLERY PLATE GASKET
190 1 2014502725 FLUID GALLERY COVER PLATE
200 18 2025501423 COUNTERBORE SCREW-3/8-16 UNC X 1.00,
 GRADE 8 (@ 35 FT-LBS)
210 1 2014500067 ROTOR BEARING
220 1 2014704280 BEARING RETAINER RING
230 1 2014500524 ROTOR BEARING
240 2 2014500531 ROTOR BEARING
250 1 2014500530 ROTOR BEARING
260 16 2014501488 COMPRESSION SPRING
270 1 2014500858 BEARING RETAINER
280 3 2014700296 COUNTERBORE SCREW-3/8-16 UNC X 3.00,
 GRADE 8 (@ 45 FT-LBS, BACK OFF TO 25 FT-LBS)
290 1 2014700558 VITON O-RING-4.38 I.D.
300 1 2014501448 FLUID PUMP ADAPTER
310 1 2014500846 ROTOR SHIM-TEMPERED STEEL/BRASS
320 1 2014500580 ROTOR SHIM-TEMPERED STEEL/BRASS
330 1 2014501450 BEARING RETAINER
340 3 2014700291 COUNTERBORE SCREW-3/8-16 UNC X 1.25,
 GRADE 8 (@ 45 FT-LBS, BACK OFF TO 25 FT-LBS)
350 1 2014700641 VITON O-RING-5.25 I.D.
360 1 2014300670 DISCHARGE END CAP
370 8 2014700299 COUNTERBORE SCREW-1/2-13 UNC X 1.50,
 GRADE 8 (@ 75 FT-LBS)
380 1 2014502674 FLUID PUMP GASKET
390 1 2014500124 COMPRESSOR FLUID PUMP
400 2 2010356525 PIPE PLUG-3/4-16 (O-RING)
410 1 2014701185 45° MALE ELBOW-0.25 TUBE X 0.12 NPT
420 3 2013200486 PLUG ORIFICE-0.125 NPT
450 1 2014100578 PATENT PLATE
460 2 2014704468 DATA PLATE PIN
470 4 2013900269 LIFT VALVE (INCLUDES O-RING 22749-141)
 
COMPONENT MAINTENANCE PARTS
 A 11 2010356518 VITON O-RING-0.35 I.D.
 B 3 2010356498 VITON O-RING-0.64 I.D.
 * ITEMS NOT SOLD SEPARATELY, MUST BE ORDERED AS A COMPLETE AIREND.
 ** QUANTITY AS REQUIRED.
 *** THIS CONFIGURATION (FEMALE PUMP DRIVE) IS USED ONLY ON QSI-250I/50 HZ & 300I/60 HZ.

 - QSI 245i/300i 19
Discharge Piping - 2011018427
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2013201903 MANIFOLD,DISCHARGE,QSI 245I/30
20 1 1627450152 COUPLING,FLEXPIPE,RESTR,200
30 1 2014700599 O-RING,VITON--,0.19W, 2.50ID
40 4 2025501571 WASHER,HLOC.500CRS,ZN,.125 THK
50 2 2014700431 NUT,LOK,.50 NC,SAE 2,NONE
60 2 5530933500 SCREW,CAP,CS,HEX ,ZN.50NCX7.50
70 4 2025501365 SCREW,CAP,CS,HEX ,ZN.50NCX1.50
 GRADE 5 (@ 23 FT-LBS)

CORRECTED MANIFOLD (ITEM 1) PART NUMBER (12/15/08).
20  - QSI 245i/300i
Drive Coupling - 2011004129
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 2 2013305260 GUARD,COUPLING,UNIVERSAL
20 1 2014200250 COUPLING,DRIVE,1.88MOTX1.69COM
30 6 2014700069 SCREW,CAP,WHIZLOCK,5/16-18X.75
40 1 2014704418 KEY,SQUARE-,.38WX.38HX1.75L
COMPONENT MAINTENANCE PARTS
 A 1 1627423003 ELEMENT,COUPLING,DRIVE
 (1 PAIR OF HALVES SOLD AS A MATCHED SET ONLY)
 B 1 2014200318 HUB,COMPRESSOR,1.69BOR,E20
 C 1 1627455884 HUB,MOTOR,1.88BOR
 D 1 2012100493 KT,BOLT,COUPLING,DRIVE
 - QSI 245i/300i 21
Drive Coupling - 2011004131
22  - QSI 245i/300i
Drive Coupling - 2011004131
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2014704418 KEY,SQUARE-,.38WX .38HX1.75L
20 1 2014200250 COUPLING,DRIVE,1.88MOTX1.69COM
30 2 2013305260 GUARD,COUPLING,UNIVERSAL
40 6 2014700069 SCREW,CAP,WHIZLOCK,5/16-18X.75
COMPONENT MAINTENANCE PARTS
 A 1 1627423003 ELEMENT,COUPLING,DRIVE
 (1 PAIR OF HALVES SOLD AS A MATCHED SET ONLY)
 B 1 2014200318 HUB,COMPRESSOR,1.69BOR,E20
 C 1 1627455884 HUB,MOTOR,1.88BOR
 D 1 2012100493 KT,BOLT,COUPLING,DRIVE
 - QSI 245i/300i 23
Electrical Control & Starting (standard PLC control) 
PIX5112
24  - QSI 245i/300i
Electrical Control & Starting (standard PLC control)
ITEM NO. QTY. PART NUMBER DESCRIPTION
 1 1 2014100320 DECAL,PANEL,CONTROL,QSI(I)
 2 1 2013700415 AY,BLOCK,TERM,QSI,ELE
 3 1 1627409048 DECAL SHEET,ELECTRICAL
 4 1 2014002154 CHIP,PLC,PROGRMMED,STDCTRL,QSI
 5 1 2014000913 PLC,CNTRLR,24RCO,24VAC
 6 1 2014000891 BUTTON,ESTOP,1/4 TURN ,SIEMENS
 1 2010356647 CONTACT,1 NC,SIEMENS (NORMALLY CLOSED) 
 7 1 2014000894 BUTTON,MOMENTARY,GREEN,ILL
 1 2014000702 LAMP,S-ST,GREEN,120VAC
 8 2 2014000893 LENS,INDICATOR,RED
 2 1627441088 LAMP,S-ST, RED,120VAC
 9 1 2014705947 SWITCH,SELECTOR,2-POSITION,MNT
 1 2010356648 CONTACT,1 NO,SIEMENS (NORMALLY OPEN) 
 1 2010356647 CONTACT,1 NC,SIEMENS (NORMALLY CLOSED) 
 10 1 2014100346 PLATE,LEGEND,AUX MTR OVERLOAD
 1 2014100360 PLATE,LEGEND,COMP 1 FAULT
 1 2014100368 PLATE,LEGEND,LEAD/LAG
 11 2 2025501469 TERMINAL,GRND,14AWG-2AWG
 12 2 2014706101 SWITCH,TMP,230F 230-242,0,SPST
 13 1 2014704058 BLOCK,POWER, 14- 4 AWG
 14 1 2014704059 BLOCK,POWER, 6-350 AWG
 15 2 2014703691 RELAY,SOCKET,15AMP/120VAC,DPDT (REDUCED VOLTAGE) 
 16 1 2014706268 TRANS,500VA,MULTIPRI,120/24SEC
 17 1 2014000805 HOLDER,FUSE,30A,L/IND,CL CC,3P
 18 2 (PAGE 32) TRANSFORMER FUSE (PRIMARY) 
 19 1 1089916827 FUSE,600/5.00TD,0.41DIAX1.50LG (SECONDARY) 
 20 1 2014000803 HOLDER,FUSE,30A,L/IND,CL CC,1P
 21 1 1089916834 FUSE,600/6.00TD,0.41DIAX1.50LG (SECONDARY) 
 22 1 1627441002 METER,HOUR,MINI,120V AC,60HZ
 1 1627441003 METER,HOUR,MINI,120V AC,50HZ
 23* 1 2010301995 PHASE MONITOR (200/230 VOLT) 
 1 2010300589 PHASE MONITOR (380/415 VOLT) 
 1 2010300588 PHASE MONITOR (460 VOLT) 
 1 2010300430 PHASE MONITOR (575 VOLT) 
 24 1 (PAGE 32) DRIVE MOTOR CONTACTOR (FULL VOLTAGE & WYE-DELTA) 
 1 (PAGE 32) REDUCED VOLTAGE STARTER 
 25 1 (PAGE33) DRIVE MOTOR OVERLOAD RELAY 
 26** 3 2014703413 TRANSFORMER,CURRENT,300 AMPS (NOT SHOWN) 
 3 2014703414 TRANSFORMER,CURRENT,600 AMPS (NOT SHOWN) 
 27 1 1089941547 CONTACTOR,120V
 (ALL 75 HP AND 100 HP, 380-575 VOLT) 
 1 1089941524 CONTACTOR,120V
 28 1 (PAGE33) FAN MOTOR OVERLOAD RELAY 
 29 1 2014000805 HOLDER,FUSE,30A,L/IND,CL CC,3P
 30 3 (PAGE33) FAN MOTOR FUSE 
 * ITEM 21 (PHASE MONITOR) IS OPTIONAL.
 ** 2014703413 CURRENT TRANSFORMER USED ONLY WITH 2014703815 RELAY,OVERLOAD,100- 
 300AMP,CL20
FILME Compressor
26  - QSI 245i/300i
Electrical Control & Starting (electronic control) 
ITEM NO. QTY. PART NUMBER DESCRIPTION
1 1 2013700553 BEZEL,QSI
2 1 2013700415 AY,BLOCK,TERM,QSI,ELE
3 1 1627409048 DECAL SHEET,ELECTRICAL
4 1 2010314321 USE 2012102102 REPLACEMENT KIT
5 1 1627441148 PLC,14DC INPUT,10RL OUTPUT,120
6 1 2014000891 BUTTON,ESTOP,1/4 TURN ,SIEMENS
 1 1089036258 CONTACT,2 NC,SIEMENS
7 2 2025501469 TERMINAL,GRND,14AWG-2AWG
8 1 2010312639 USE 2014000023
9 1 2014706101 SWITCH,TMP,230F 230-242,0,SPST
10 1 2014704058 BLOCK,POWER, 14- 4 AWG
11* 1 2014704059 BLOCK,POWER, 6-350 AWG
 1 2014704024 BLOCK,POWER, 6-500 AWG,3 POLE
12** 2 2014703691 RELAY,SOCKET,15AMP/120VAC,DPDT
13 1 2014000848 TRANSD,PRS,0-300 PSIG,4-20MA
14 1 2014706268 TRANS,500VA,MULTIPRI,120/24SEC
15 1 2014000805 HOLDER,FUSE,30A,L/IND,CL CC,3P
16 2 (PAGE 32) TRANSFORMER FUSE (PRIMARY) 
17 1 1089916827 FUSE,600/5.00TD,0.41DIAX1.50LG
18 1 2014000803 HOLDER,FUSE,30A,L/IND,CL CC,1P
19 1 1089916834 FUSE,600/6.00TD,0.41DIAX1.50LG
20 1 2014000909 METER,HOUR,120VAC,60HZ,DIN MNT
 1 2014000908 METER,HOUR,120VAC,50HZ,DIN MNT
21*** 1 2010301995 USE 2014703800
 1 2010300589 USE 2014703800
 1 2010300588 USE 2012102144
 1 2010300430 USE 2014703800
22 1 (PAGE 32) DRIVE MOTOR CONTACTOR (FULL VOLTAGE & WYE-DELTA)
 1 (PAGE 32) REDUCED VOLTAGE STARTER 
23 1 (PAGE33) DRIVE MOTOR OVERLOAD RELAY 
24**** 3 2014703413 TRANSFORMER,CURRENT,300 AMPS
 3 2014703414 TRANSFORMER,CURRENT,600 AMPS
25 1 1089941547 CONTACTOR,120V
26 1 (PAGE33) FAN MOTOR OVERLOAD RELAY 
27 1 2014000805 HOLDER,FUSE,30A,L/IND,CL CC,3P

1 1 2013700553 BEZEL,QSI
2 1 2013700416 AY,BLOCK,TERM,QSI,P$
3 1 1627409048 DECAL SHEET,ELECTRICAL
4 1 2010314321 USE 2012102102 REPLACEMENT KIT
5 1 2014000900 PLC,24DC INPUT,16RL OUTPUT,120
6 1 2014000891 BUTTON,ESTOP,1/4 TURN ,SIEMENS
6 1 1089036258 CONTACT,2 NC,SIEMENS (NORMALLY CLOSED)
7 2 2025501469 TERMINAL,GRND,14AWG-2AWG
8 2 2010312639 USE 2014000023
9 1 1627441153 MODULE , ANALOG ,4 INPUT
10 1 2014704058 BLOCK,POWER, 14- 4 AWG
11* 1 2014704059 BLOCK,POWER, 6-350 AWG
 1 2014704024 BLOCK,POWER, 6-500 AWG,3 POLE
12* 2 2014703682 RELAY,8 AMP/120VAC,DPDT,ASSY
13 2 2014000848 TRANSD,PRS,0-300 PSIG,4-20MA
14 1 2014000903 CHIP,200DAY BATTERY BACKUP,S7
15** 1 2010301995 USE 2014703800
 1 2010300589 USE 2014703800
 1 2010300588 USE 2012102144
 1 2010300430 USE 2014703800
16 1 2014706268 TRANS,500VA,MULTIPRI,120/24SEC
17 1 2014000805 HOLDER,FUSE,30A,L/IND,CL CC,3P
18 2 (PAGE 32) TRANSFORMER FUSES (PRIMARY) 
19 1 1089916827 FUSE,600/5.00TD,0.41DIAX1.50LG (SECONDARY) 
20 1 2014000803 HOLDER,FUSE,30A,L/IND,CL CC,1P
21 1 1089916834 FUSE,600/6.00TD,0.41DIAX1.50LG (SECONDARY) 
22 1 2014000909 METER,HOUR,120VAC,60HZ,DIN MNT
23 (PAGE 32) DRIVE MOTOR CONTACTOR 
 1 (PAGE 32) REDUCED VOLTAGE STARTER 
24 1 (PAGE33) DRIVE MOTOR OVERLOAD RELAY 
25*** 3 2014703413 TRANSFORMER,CURRENT,300 AMPS
26 1 (PAGE33) FAN MOTOR CONTACTOR 
27 1 (PAGE33) FAN MOTOR OVERLOAD RELAY 
**** 1 (PAGE33) VARIABLE FREQUENCY FAN MOTOR DRIVE 
28 1 2014000805 HOLDER,FUSE,30A,L/IND,CL CC,3P
29 3 (PAGE33) FAN MOTOR FUSES 
30 1 2013700560 ENCL,BACKUP CONTROL,QSI-I
31 1 2013700562 COVER,ENCL,BACKUP CONTROL,QSI
32 1 2013700563 GASKET,ENCL,BACKUP CONTROL,QSI
33 1 2014705947 SWITCH,SELECTOR,2-POSITION,MNT
34 1 2014100364 PLATE,LEGEND,P$/BACKUP
35 1 2014000894 BUTTON,MOMENTARY,GREEN,ILL
36 1 2014100363 PLATE,LEGEND,START
37 1 2014000913 PLC,CNTRLR,24RCO,24VAC
38 1 2014704338 SWITCH,PRS,OPEN ,207LB,18DIF
 
 * NOT USED ON ALL UNITS.
 NUMBER FOR USAGE & CORRECT PART NUMBER.
 ** ITEMS 15 (PHASE MONITOR) & 30 THRU 38 (BACKUP CONTROL) ARE OPTIONAL.
 *** 2014703413 CURRENT TRANSFORMER USED ONLY WITH 2014703815 RELAY,OVERLOAD,
 100-300AMP,CL20
 2014703414 CURRENT TRANSFORMER USED ONLY WITH 2014703807 RELAY,OVERLOAD,
 200-600AMP,CL20.
 **** THIS ITEM NOT SHOWN (NOT LOCATED INSIDE ELECTRICAL ENCLOSURE). USED ONLY ON 
 125 HP UNITS.
 (ITEMS 26 & 27 NOT USED ON 125 HP UNITS.)
 - QSI 245i/300i 29
Electrical Control & Starting 
2014002410
30  - QSI 245i/300i
Electrical Control & Starting
ITEM NO. QTY. PART NUMBER DESCRIPTION
1 1 1900520025 Q-CONTROL 
2 1 2014000891 EMERGENCY STOP BUTTON 
3 1 2014000803 FUSE BLOCK-1 POLE 
 1 2014000805 FUSE BLOCK-3 POLE 
4 1 2230050005 ICONS 
5 1 2230050005 POWER SUPPLY FOR ICONS 
6 1 2014706268 TRANSFORMER-500VA,MULTIPRIMARY, 120/24 SEC. 
7 1 1900520037 I/O MODULE 
8 1 2013700960 TERMINAL BLOCK, QSI 
9* 1 2014703800 PHASE MONITOR(200V-690V) 
10** 1 2014703682 RELAY-DPDT,8 AMP/120VAC 
11 1 (SEE PAGE 33) OVERLOAD DISCONNECT 
 1 (SEE PAGE 33) OVERLOAD DISCONNECT 
 1 (SEE PAGE 33) OVERLOAD DISCONNECT 
 1 (SEE PAGE 33) OVERLOAD DISCONNECT 
 1 (SEE PAGE 33) OVERLOAD DISCONNECT 
12 1 1089941547 FAN CONTACTOR-120V 
13 1 (SEE PAGE 32) SOLID STATE STARTER 
 1 (SEE PAGE 32) SOLID STATE STARTER 
 1 (SEE PAGE 32) SOLID STATE STARTER 
 1 (SEE PAGE 32) SOLID STATE STARTER 
 1 (SEE PAGE 32) SOLID STATE STARTER 
 1 (SEE PAGE 32) SOLID STATE STARTER 
14*** 1 (SEE PAGE 32) DRIVE MOTOR CONTACTOR-120V 
 1 (SEE PAGE 32) DRIVE MOTOR CONTACTOR-120V 
 1 (SEE PAGE 32) DRIVE MOTOR CONTACTOR-120V 
 1 (SEE PAGE 32) DRIVE MOTOR CONTACTOR-120V 
 1 (SEE PAGE 32) DRIVE MOTOR CONTACTOR-120V 
 1 (SEE PAGE 32) DRIVE MOTOR CONTACTOR-120V 
 1 (SEE PAGE 32) DRIVE MOTOR CONTACTOR-120V 
 1 (SEE PAGE 32) DRIVE MOTOR CONTACTOR-120V 
 1 (SEE PAGE 32) DRIVE MOTOR CONTACTOR-120V 
 1 (SEE PAGE 32) DRIVE MOTOR CONTACTOR-120V 
15*** 1 (SEE PAGE 33) OVERLOAD RELAY 
16*** 1 (SEE PAGE 33) OVERLOAD RELAY 
 1 (SEE PAGE 33) OVERLOAD RELAY 
17 1 2014704058 POWER BLOCK 
18 1 2014704069 POWER BLOCK(ONLY FOR WYE-DELTA) 
19 1 2013700964 BUSS,GROUNDING
20 2 2014704246 TERMINAL GROUND
21 1 1089057470 TEMPERATURE SENSOR
22 1 1089057554 PRESSURE TRANSDUCER
FILME Compressor
 ** QUANTITY OF 2 REQUIRED ON SOLID STATE STARTER AND REMOTE START.
 *** ITEMS NOT REQUIRED FOR SOLID STATE AND REMOTE STARTS.
 - QSI 245i/300i 31
Electrical Control & Starting (all control types) 
 ITEM 18/16 TRANSFORMER FUSE (PRIMARY)
 VOLTAGE QTY. 
 200 2 2014702978
 230 2 1089916826
 380 2 1089916825
 415 2 1089916824
 460 2 2014702977
 575 2 2014702980
ITEM 24/22 DRIVE MOTOR CONTACTOR
 FULL VOLTAGE
 VOLTAGE QTY. 50 HP 60 HP
 200 1 1089941563 1089941581
 230 1 1089941562 1089941563
 380 1 1089941545 1089941561
 415 1 1089941545 1089941561
 460 1 1089941545 1089941546
 575 1 2010356445 1089941545
 WYE-DELTA
 VOLTAGE QTY. 50 HP QTY. 60 HP
 200 1 1089941546 2 1089941561
 1 2010356445 
 230 1 1089941546 2 1089941561
 1 2010356445 
 380 2 2010356445 1 1089941545
 1 2010356445 
 415 1 2010356444 2 2010356445
 1 2010356442 
 460 1 2010356444 2 2010356445
 1 2010356442 
 575 1 2010356443 1 2010356444
 1 2010356442 1 2010356442
ITEM 24/22 REDUCED VOLTAGE STARTER
 VOLTAGE QTY. 50 HP 60 HP
 200 1 1089962903 1089962903
 230 1 1089962903 1089962903
 380 1 1089962901 1089962901
 415 1 1089962901 1089962901
 460 1 2014705666 1089962901
 575 1 2014705656 2014705657
32  - QSI 245i/300i
Electrical Control & Starting (all control types) 
 ITEM 25/23 DRIVE MOTOR/STARTER OVERLOAD RELAY
 FULL VOLTAGE WYE-DELTA REDUCED VOLTAGE
 VOLTAGE QTY. 50 HP 60 HP 50 HP 60 HP 50 HP 60 HP
 200 1 2014703815 2014703815 2014703810 2014703810 N/A N/A
 230 1 2014703815 2014703815 2014703815 2014703810 N/A N/A
 380 1 2014703815 2014703810 2014703810 2014703810 N/A N/A
 415 1 2014703815 2014703810 2014703810 2014703810 N/A N/A
 460 1 2014703815 2014703815 2014703805 2014703810 2014703815 2014703815
 575 1 2014703810 2014703815 2014703805 2014703805 2014703810 2014703815
ITEM 28/26 FAN MOTOR OVERLOAD RELAY
 VOLTAGE QTY.
 200 1 2014703809
 230 1 2014703809
 380 1 2014703809
 415 1 2014703809
 460 1 2014703817
 575 1 2014703817
ITEM 30/28 FAN MOTOR FUSES
 VOLTAGE QTY.
 200 3 2014702981
 230 3 2014703054
 380 3 2014703052
 415 3 1089916827
 460 3 2014702978
 575 3 2014703051
 PHASE MONITOR FUSES (OPTIONAL)
 VOLTAGE QTY.
 200 3 2014702981
 230 3 2014703054
 380 3 2014703052
 415 3 1089916827
 460 3 2014702978
 575 3 2014703051
 - QSI 245i/300i 33
Control Piping (standard PLC control) - 2011015643
34  - QSI 245i/300i
Control Piping (standard PLC control) - 2011015643
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 15 2014701663 FIT T,ELBOW,FLLS,025NTX025MPX9
20 4 2025500485 FIT P,TEE--,BRASS,M025X025X025
30 1 2014701357 FIT T,CONEC,37FL,025STX025MP
40 1 1627441144 AY,CABLE,DIN CONN.,7 METER
50 2 2013700538 AY,CABLE,DIN CONN.,7 METER
60 1 2014701303 FIT P,CPLG,BRASS,012X012BLKHD
70 1 2014701305 FIT P,CPLG,BRASS,025X025BLKHD
80 1 2014702444 NIPPLE,SCH40,TBE,GLV,038X02.75
90 1 2014706335 VALVE,SOL,3-WAY,NO,025P,24VAC
100 1 2014701372 FIT P,BUSHG,BRASS, 038X025 HEX
110 1 2014705949 SWITCH,VACUUM,25” WATER
120 4 2014705091 TUBE-FT,STSTL CFS,.25ODX.035W
130 1 2014701102 FIT T,ELBOW,FLLS,025STX025MPX9
140 7 2014702228 NIPPLE,BRASS,TBE, XS,025XCLOSE
150 1 2014701339 FIT,CONN,SWVL,1/4TUBEX1/4PIPE
160 1 1627404059 VALVE,ANGLE,NEEDLE,025NTX012MP
170 2 2014701752 FIT P,CPLG,BRASS, 012X012
180 2 1627434018 FILTER,LINE,025NPT,AUTO-DRAIN
190 1 2014704129 VALVE,CHK,IN-LINE,025P,200PSI
200 47 2014705166 TUBE-FT,1/4 NYLON 11,BLACK
210 1 2013900236 VALVE,BLOWDOWN,1/4NPT
220 1 2014701665 FIT T,ELBOW,FLLS,038NTX025MPX9
230 1 2014704306 SWITCH,PRS,OPEN ,110LB,15DIF
240 1 2010344926 FIT T,ELBOW,37FL,025STX025MPX9
250 1 2013201852 AY,HOSEF0.25 51.00 1500WP
260 1 2014701666 FIT T,ELBOW,FLLS,038NTX038MPX9
270 5 2014705167 TUBE-FT,3/8 NYLON 11,BLACK
280 5 2014701375 FIT P,ELBOW,BRASS,M025X025X90
290 2 2013900054 AY,VALVE,CHECK,GAUGE,CAPACITY
300 3 2025500418 FIT P,PLUG-,300PLN 025 HX SOCK
310 1 2013200637 SIGHTGLASS,1/4NPT,300PSI
320 1 2013400080 FILTER,LINE,.040 DIA,.25 NPT
330 1 1627433006 GAUGE,PRS,0-300,2.50,1/4CBK
340 1 2014701897 FIT T,TEE--,COMP,025CTX012MP
350 2 2014700680 FIT T,CONEC,BITE,025STX025MP
360 1 2013202217 DASH-POT PRESSURE GAUGE
370 1 1627433009 GAUGE,THERMO,ASSEMBLY,SAE&NPT
380 2 1627404072 VALVE,SHUTTLE,025P
390 1 2025500486 FIT P,TEE--,BRASS,M012X012X012
400 1 2014704297 SWITCH,PRS,10 PSID DIF
410 1 1627433007 GAUGE,CAPACITY,0-100%
420 1 2010318726 FIT T,ELBOW,37FL,025STX012MPX9
430 2 2014702229 NIPPLE,BRASS,TBE, XS,012XCLOSE
440 3 2014701945 FIT T,CONEC,FLLS,025NTX025MP
450 1 2013304095 BRACKET,SUPPORT,CONTROL PIPE
460 1 1627404081 VALVE,PRESREG,025P,75-175PSI
470 1 2014701101 FIT T,ELBOW,BITE,025STX012MPX9
480 1 2025500275 FIT P,TEE--,BRASS, 025X025X025
490 1 2025500648 NIPPLE,BRASS,TBE,012X025,CLOSE
500 1 0581120067 FIT T,ELBOW,COMP,025CTX012MPX9
510 1 1627456109 GROMMET,RUBBER,0.81ID,0.94GD
520 1 2014704298 SWITCH,PRS,19 PSID DIF
600 1 2014700690 FIT T,CONEC,BITE,025STX025FP
610 1 2014700843 FIT T,VIBRA-LOK,.25STX.25MP
COMPONENT MAINTENANCE PARTS
A 1 1627456261 KT,REPAIR,PILOT
 (INCLUDES DIAPHRAGM ASSEMBLY & SEAT)
B 4 2010356483 O-RING,BUNA-N ,0.06W, 0.18ID
C 2 2025501056 O-RING,VITON ,0.06W, 0.25ID
 1 2010356518 O-RING,VITON--,0.072W,0.351ID
 - QSI 245i/300i 35
Control Piping (standard PLC control) - 2011015645
36  - QSI 245i/300i
Control Piping (standard PLC control) - 2011015645
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2013900236 VALVE,BLOWDOWN,1/4NPT
20 7 2014702228 NIPPLE,BRASS,TBE, XS,025XCLOSE
30 1 2014701357 FIT T,CONEC,37FL,025STX025MP
40 1 2013200637 SIGHTGLASS,1/4NPT,300PSI
50 1 2014704297 SWITCH,PRS,10 PSID DIF
60 4 2014705091 TUBE-FT,STSTL CFS,.25ODX.035W
70 1 2013201852 AY,HOSEF0.25 51.00 1500WP
80 25 2014705166 TUBE-FT,1/4 NYLON 11,BLACK
90 5 2014705167 TUBE-FT,3/8 NYLON 11,BLACK
100 1 1627404081 VALVE,PRESREG,025P,75-175PSI
110 1 2014706335 VALVE,SOL,3-WAY,NO,025P,24VAC
120 1 1627456109 GROMMET,RUBBER,0.81ID,0.94GD
130 1 2014704298 SWITCH,PRS,19 PSID DIF
140 1 2014704338 SWITCH,PRS,OPEN ,207LB,18DIF
150 2 2014701752 FIT P,CPLG,BRASS, 012X012
160 2 2014700680 FIT T,CONEC,BITE,025STX025MP
170 1 2010318726 FIT T,ELBOW,37FL,025STX012MPX9
180 1 1627441144 AY,CABLE,DIN CONN.,7 METER
190 1 1627404059 VALVE,ANGLE,NEEDLE,025NTX012MP
200 1 1627433006 GAUGE,PRS,0-300,2.50,1/4CBK
210 2 2013900054 AY,VALVE,CHECK,GAUGE,CAPACITY
220 1 2014701665 FIT T,ELBOW,FLLS,038NTX025MPX9
230 1 2014701305 FIT P,CPLG,BRASS,025X025BLKHD
240 2 2014702229 NIPPLE,BRASS,TBE, XS,012XCLOSE
250 1 1627433007 GAUGE,CAPACITY,0-100%
260 2 1627434018 FILTER,LINE,025NPT,AUTO-DRAIN
270 1 0581120067 FIT T,ELBOW,COMP,025CTX012MPX9
280 1 2010344926 FIT T,ELBOW,37FL,025STX025MPX9
290 3 2014701945 FIT T,CONEC,FLLS,025NTX025MP
300 2 2013700538 AY,CABLE,DIN CONN.,7 METER
310 1 2014704129 VALVE,CHK,IN-LINE,025P,200PSI
320 4 2025500485 FIT P,TEE--,BRASS,M025X025X025
330 1 2014701897 FIT T,TEE--,COMP,025CTX012MP
340 1 2014701303 FIT P,CPLG,BRASS,012X012BLKHD
350 5 2014701375 FIT P,ELBOW,BRASS,M025X025X90
360 1 2014701102 FIT T,ELBOW,FLLS,025STX025MPX9
370 1 2014701101 FIT T,ELBOW,BITE,025STX012MPX9
380 1 2025500486 FIT P,TEE--,BRASS,M012X012X012
390 1 2014701339 FIT,CONN,SWVL,1/4TUBEX1/4PIPE
400 1 2025500275 FIT P,TEE--,BRASS, 025X025X025
410 15 2014701663 FIT T,ELBOW,FLLS,025NTX025MPX9
420 1 2025500648 NIPPLE,BRASS,TBE,012X025,CLOSE
430 1 2014702232 NIPPLE,BRASS,TBE, XS,025X02.00
440 2 1627404072 VALVE,SHUTTLE,025P
450 1 2014705949 SWITCH,VACUUM,25” WATER
460 1 1627433009 GAUGE,THERMO,ASSEMBLY,SAE&NPT
470 1 2014701372 FIT P,BUSHG,BRASS, 038X025 HEX
480 1 2014701666 FIT T,ELBOW,FLLS,038NTX038MPX9
490 4 2025500418 FIT P,PLUG-,300PLN 025 HX SOCK
500 1 2013304095 BRACKET,SUPPORT,CONTROL PIPE
510 1 2013202217 DASH-POT PRESSURE GAUGE
520 1 2013400080 FILTER,LINE,.040 DIA,.25 NPT
600 1 2014700690 FIT T,CONEC,BITE,025STX025FP
610 1 2014700843 FIT T,VIBRA-LOK,.25STX.25MP
 - QSI 245i/300i 37
Control Piping (standard PLC control) - 2011014967
38  - QSI 245i/300i
Control Piping (standard PLC control) - 2011014967
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2014705166 TUBE-FT,1/4 NYLON 11,BLACK
20 1 2013202217 DASH-POT PRESSURE GAUGE
30 1 1627404081 VALVE,PRESREG,025P,75-175PSI
40 1 2014702232 NIPPLE,BRASS,TBE, XS,025X02.00
50 1 2014701357 FIT T,CONEC,37FL,025STX025MP
60 1 2014704297 SWITCH,PRS,10 PSID DIF
70 5 2014705167 TUBE-FT,3/8 NYLON 11,BLACK
80 8 2014702228 NIPPLE,BRASS,TBE, XS,025XCLOSE
90 1 2014706335 VALVE,SOL,3-WAY,NO,025P,24VAC
100 5 2014701375 FIT P,ELBOW,BRASS,M025X025X90
110 1 1627456109 GROMMET,RUBBER,0.81ID,0.94GD
120 1 2014701101 FIT T,ELBOW,BITE,025STX012MPX9
130 1 2014701753 FIT P,CPLG,BRASS, 025X025
140 1 2014701665 FIT T,ELBOW,FLLS,038NTX025MPX9
150 1 1627441144 AY,CABLE,DIN CONN.,7 METER
160 1 2014704298 SWITCH,PRS,19 PSID DIF
170 1 2014705949 SWITCH,VACUUM,25” WATER
180 1 2013900236 VALVE,BLOWDOWN,1/4NPT
190 2 1627404072 VALVE,SHUTTLE,025P
200 1 2013900054 AY,VALVE,CHECK,GAUGE,CAPACITY
210 1 2013200637 SIGHTGLASS,1/4NPT,300PSI
220 1 2013400080 FILTER,LINE,.040 DIA,.25 NPT
230 1 1627404059 VALVE,ANGLE,NEEDLE,025NTX012MP
240 2 2013700538 AY,CABLE,DIN CONN.,7 METER
250 1 2014702234 NIPPLE,BRASS,TBE, XS,025X01.25
260 1 2014702229 NIPPLE,BRASS,TBE, XS,012XCLOSE
270 1 2025500648 NIPPLE,BRASS,TBE,012X025,CLOSE
280 2 2014700680 FIT T,CONEC,BITE,025STX025MP
290 1 2014701666 FIT T,ELBOW,FLLS,038NTX038MPX9
300 1 2014701339 FIT,CONN,SWVL,1/4TUBEX1/4PIPE
310 1 2014701372 FIT P,BUSHG,BRASS, 038X025 HEX
320 1 2014701303 FIT P,CPLG,BRASS,012X012BLKHD
330 1 2013201852 AY,HOSEF0.25 51.00 1500WP
340 2 2014705091 TUBE-FT,STSTL CFS,.25ODX.035W
350 3 2025500485 FIT P,TEE--,BRASS,M025X025X025
360 1 2014701102 FIT T,ELBOW,FLLS,025STX025MPX9
370 1 2010318726 FIT T,ELBOW,37FL,025STX012MPX9
380 1 2010344926 FIT T,ELBOW,37FL,025STX025MPX9
390 2 1627434018 FILTER,LINE,025NPT,AUTO-DRAIN
400 1 2025500275 FIT P,TEE--,BRASS, 025X025X025
410 1 2025500486 FIT P,TEE--,BRASS,M012X012X012
420 2 2014701945 FIT T,CONEC,FLLS,025NTX025MP
430 1 2014704129 VALVE,CHK,IN-LINE,025P,200PSI
440 9 2014701663 FIT T,ELBOW,FLLS,025NTX025MPX9
450 3 2025500418 FIT P,PLUG-,300PLN 025 HX SOCK
460 1 2014701752 FIT P,CPLG,BRASS, 012X012
470 1 2014701897 FIT T,TEE--,COMP,025CTX012MP
480 1 0581120067 FIT T,ELBOW,COMP,025CTX012MPX9
500 1 2014700690 FIT T,CONEC,BITE,025STX025FP
610 1 2014700843 FIT T,VIBRA-LOK,.25STX.25MP
 - QSI 245i/300i 39
Control Piping (standard PLC control) - 2011014971
40  - QSI 245i/300i
Control Piping (standard PLC control) - 2011014971
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2013900236 VALVE,BLOWDOWN,1/4NPT
20 5 2025500418 FIT P,PLUG-,300PLN 025 HX SOCK
30 1 2013200637 SIGHTGLASS,1/4NPT,300PSI
40 1 2013700538 AY,CABLE,DIN CONN.,7 METER
50 1 2014701303 FIT P,CPLG,BRASS,012X012BLKHD
60 1 2014701666 FIT T,ELBOW,FLLS,038NTX038MPX9 
70 3 2014705091 TUBE-FT,STSTL CFS,.25ODX.035W
80 1 2025500648 NIPPLE,BRASS,TBE,012X025,CLOSE 
90 1 0581120067 FIT T,ELBOW,COMP,025CTX012MPX9
100 1 2013201852 AY,HOSEF0.25 51.00 1500WP
110 7 2014702228 NIPPLE,BRASS,TBE, XS,025XCLOSE 
120 1 2013202217 DASH-POT PRESSURE GAUGE
130 1 2014701372 FIT P,BUSHG,BRASS, 038X025 HEX
140 2 1627434018 FILTER,LINE,025NPT,AUTO-DRAIN
150 1 2014701753 FIT P,CPLG,BRASS, 025X025
160 2 2014706335 VALVE,SOL,3-WAY,NO,025P,24VAC
170 1 2014701665 FIT T,ELBOW,FLLS,038NTX025MPX9
180 1 2010318726 FIT T,ELBOW,37FL,025STX012MPX9 
190 2 1627441144 AY,CABLE,DIN CONN.,7 METER 
200 1 2014704298 SWITCH,PRS,19 PSID DIF
210 1 2010344926 FIT T,ELBOW,37FL,025STX025MPX9
220 1 2014701101 FIT T,ELBOW,BITE,025STX012MPX9
230 1 2014700680 FIT T,CONEC,BITE,025STX025MP
240 1 1627404081 VALVE,PRESREG,025P,75-175PSI
250 1 2013305613 BRACKET,BANK,SOLENOID
260 8 2014701904 FIT T,CONEC,FLLS,025NTX012MP
270 3 2014701945 FIT T,CONEC,FLLS,025NTX025MP
280 1 2014702232 NIPPLE,BRASS,TBE, XS,025X02.00
290 4 2014701375 FIT P,ELBOW,BRASS,M025X025X90
300 1 2013400080 FILTER,LINE,.040 DIA,.25 NPT
310 1 2014701897 FIT T,TEE--,COMP,025CTX012MP
320 1 1627456109 GROMMET,RUBBER,0.81ID,0.94GD
330 5 2014705167 TUBE-FT,3/8 NYLON 11,BLACK
340 8 1627450284 ORIFICE,PLUG ,0.062ID,0.202OD
350 2 1627404072 VALVE,SHUTTLE,025P
360 28 2014705166 TUBE-FT,1/4 NYLON 11,BLACK
370 1 2014702229 NIPPLE,BRASS,TBE, XS,012XCLOSE
380 22 2014701663 FIT T,ELBOW,FLLS,025NTX025MPX9
390 1 2014701752 FIT P,CPLG,BRASS, 012X012
400 1 2014704129 VALVE,CHK,IN-LINE,025P,200PSI
410 1 2013700387 AY,CABLE W/VDR,5 METER,24VDC
420 1 2013900347 BANK,SOLENOID,4 VALVE,N4,24VAC
430 1 2014705949 SWITCH,VACUUM,25” WATER
440 1 2025500486 FIT P,TEE--,BRASS,M012X012X012
450 1 1627404059 VALVE,ANGLE,NEEDLE,025NTX012MP
460 1 2013900054 AY,VALVE,CHECK,GAUGE,CAPACITY
470 1 2014701357 FIT T,CONEC,37FL,025STX025MP
480 6 2025500485 FIT P,TEE--,BRASS,M025X025X025
490 1 2014701339 FIT,CONN,SWVL,1/4TUBEX1/4PIPE
500 4 2025500973 NUT,LOK,.25 NC,SAE 2,NONE
510 4 2014700107 SCREW,CAP,CS,HEX ,ZN.25NCX2.50
520 1 2013201968 TUBING,PRE-BENT,025ST,QSI-335/
600 1 2014700690 FIT T,CONEC,BITE,025STX025FP
610 1 2014700843 FIT T,VIBRA-LOK,.25STX.25MP
610 1 2014700843 FIT T,VIBRA-LOK,.25STX.25MP
 - QSI 245i/300i 41
Q-Control (electronic control) - 2011020526
42  - QSI 245i/300i
Q-Control (electronic control) - 2011020526
ITEM NO. QTY. PART NUMBER DESCRIPTION
1 10 2014701663 FIT T,ELBOW,FLLS,025NTX025MPX9
2 6 2014702228 NIPPLE,BRASS,TBE, XS,025XCLOSE
3 16 2014705166 TUBE-FT,1/4 NYLON 11,BLACK
4 1 2013900236 VALVE,BLOWDOWN,1/4NPT
5 1 2014701414 FIT T,ELBOW,FLLS,038NTX050MPX9
6 5 2014705167 TUBE-FT,3/8 NYLON 11,BLACK
7 3 2025500485 FIT P,TEE--,BRASS,M025X025X025
8 1 2013200477 GAUGE,PRS,0-200,2.50,1/4CBK,LF
9 1 1627404081 VALVE,PRESREG,025P,75-175PSI
10 2 1627404072 VALVE,SHUTTLE,025P
11 2 2014701945 FIT T,CONEC,FLLS,025NTX025MP
12 1 2014702232 NIPPLE,BRASS,TBE, XS,025X02.00
13 1 2014706335 VALVE,SOL,3-WAY,NO,025P,24VAC
14 3 2014701375 FIT P,ELBOW,BRASS,M025X025X90
15 1 2014701339 FIT,CONN,SWVL,1/4TUBEX1/4PIPE
16 1 2014701357 FIT T,CONEC,37FL,025STX025MP
17 1 2013900054 AY,VALVE,CHECK,GAUGE,CAPACITY
18 4 2025500418 FIT P,PLUG-,300PLN 025 HX SOCK
19 1 2014701665 FIT T,ELBOW,FLLS,038NTX025MPX9
20 1 2013200637 SIGHTGLASS,1/4NPT,300PSI
21 1 2013400080 FILTER,LINE,.040 DIA,.25 NPT
22 1 1627456109 GROMMET,RUBBER,0.81ID,0.94GD
23 1 2014701154 FIT T,CONEC,ORNG,025STX044MS
24 1 2014701372 FIT P,BUSHG,BRASS, 038X025 HEX
25 1 1627441144 AY,CABLE,DIN CONN.,7 METER
26 1 1627404059 VALVE,ANGLE,NEEDLE,025NTX012MP
31 2 2013700538 AY,CABLE,DIN CONN.,7 METER
32 1 2014701303 FIT P,CPLG,BRASS,012X012BLKHD
33 2 1627434018 FILTER,LINE,025NPT,AUTO-DRAIN
34 1 2014701662 FIT T,ELBOW,FLLS,025NTX012MPX9
35 1 2014701897 FIT T,TEE--,COMP,025CTX012MP
36 1 2014704129 VALVE,CHK,IN-LINE,025P,200PSI
39 2 2014701277 FIT P,PLUG-,300PLN 012 HX SOCK
COMPONENT MAINTENANCE PARTS
A 1 1627456261 KT,REPAIR,PILOT
 (INCLUDES DIAPHRAGM ASSEMBLY & SEAT)
B 4 2010356483 O-RING,BUNA-N ,0.06W, 0.18ID
C 2 2025501056 O-RING,VITON ,0.06W, 0.25ID
D 1 2010356518 O-RING,VITON--,0.072W,0.351ID
E 2 1627456101 KT,CARTRIDGE,FLTR,LINE
 - QSI 245i/300i 43
Q-Control (Power$ync control) - 2011020525
44  - QSI 245i/300i
Q-Control (Power$ync control) - 2011020525
ITEM NO. QTY. PART NUMBER DESCRIPTION
1 23 2014701663 FIT T,ELBOW,FLLS,025NTX025MPX9
2 7 2014702228 NIPPLE,BRASS,TBE, XS,025XCLOSE
3 32 2014705166 TUBE-FT,1/4 NYLON 11,BLACK
4 1 2013900236 VALVE,BLOWDOWN,1/4NPT
5 1 2014701414 FIT T,ELBOW,FLLS,038NTX050MPX9
6 5 2014705167 TUBE-FT,3/8 NYLON 11,BLACK
7 4 2025500485 FIT P,TEE--,BRASS,M025X025X025
8 1 2013200477 GAUGE,PRS,0-200,2.50,1/4CBK,LF
9 1 1627404081 VALVE,PRESREG,025P,75-175PSI
10 2 1627404072 VALVE,SHUTTLE,025P
11 3 2014701945 FIT T,CONEC,FLLS,025NTX025MP
12 1 2014702232 NIPPLE,BRASS,TBE, XS,025X02.00
13 2 2014706335 VALVE,SOL,3-WAY,NO,025P,24VAC
14 3 2014701375 FIT P,ELBOW,BRASS,M025X025X90
15 1 2014701339 FIT,CONN,SWVL,1/4TUBEX1/4PIPE
16 1 2014701357 FIT T,CONEC,37FL,025STX025MP
17 1 2013900054 AY,VALVE,CHECK,GAUGE,CAPACITY
18 6 2025500418 FIT P,PLUG-,300PLN 025 HX SOCK
19 1 2014701665 FIT T,ELBOW,FLLS,038NTX025MPX9
20 1 2013200637 SIGHTGLASS,1/4NPT,300PSI
21 1 2013400080 FILTER,LINE,.040 DIA,.25 NPT
22 1 1627456109 GROMMET,RUBBER,0.81ID,0.94GD
23 1 2014701154 FIT T,CONEC,ORNG,025STX044MS
24 1 2014701372 FIT P,BUSHG,BRASS, 038X025 HEX
25 2 1627441144 AY,CABLE,DIN CONN.,7 METER
26 1 1627404059 VALVE,ANGLE,NEEDLE,025NTX012MP
27 1 2013900347 BANK,SOLENOID,4 VALVE,N4,24VAC
28 1 2013700387 AY,CABLE W/VDR,5 METER,24VDC
29 1 2013305613 BRACKET,BANK,SOLENOID
32 8 2014701904 FIT T,CONEC,FLLS,025NTX012MP
33 8 1627450284 ORIFICE,PLUG ,0.062ID,0.202OD
35 2 1627434018 FILTER,LINE,025NPT,AUTO-DRAIN
36 1 2014701662 FIT T,ELBOW,FLLS,025NTX012MPX9
37 1 2014701897 FIT T,TEE--,COMP,025CTX012MP
38 1 2014701303 FIT P,CPLG,BRASS,012X012BLKHD
39 1 2014704129 VALVE,CHK,IN-LINE,025P,200PSI
49 1 2014701277 FIT P,PLUG-,300PLN 012 HX SOCK
COMPONENT MAINTENANCE PARTS
A 1 1627456261 KT,REPAIR,PILOT
 (INCLUDES DIAPHRAGM ASSEMBLY & SEAT)
B 4 2010356483 O-RING,BUNA-N ,0.06W, 0.18ID
C 2 2025501056 O-RING,VITON ,0.06W, 0.25ID
D 1 2010356518 O-RING,VITON--,0.072W,0.351ID
E 2 1627456101 KT,CARTRIDGE,FLTR,LINE
 - QSI 245i/300i 45
Inlet Valve - 1627501000
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 4 2025501365 SCREW,CAP,CS,HEX ,ZN.50NCX1.50
20 1 1627455887 SHAFT,VALVE,INLET
30 5 2025501571 WASHER,HLOC.500CRS,ZN,.125 THK
40 1 1627424013 AY,PLATE,VALVE,INLET
50 1 1627413013 GASKET, 6.50OD, 4.56ID, 5.50BC
60 1 1627408001 SPRING,COMP,1.09D,2.50L,0.50RT
70 1 1627456053 AY,CYLINDER,VALVE,INLET
80 1 2014701983 WASHER,FLAT .56HRS,PL,.127 THK
90 1 1627413043 GASKET,VALVE,INLET
100 1 2014300157 HOUSING,VALVE,INLET
110 1 2024805800 WASHER,FLAT.045STEEL
120 1 2025501273 SCREW,CAP,CS,HEX ,PL.50NCX1.00
130 1 2014600200 CUP,PISTON,3.50DIA,RUBBER
140 6 2025501566 WASHER,HLOK.375CRS,PL,.094 THK
150 1 2014700146 SCREW,CAP,CS,HEX ,ZN.50NCX5.00
160 1 1627413044 GASKET,VALVE,INLET
170 1 5530617000 NUT,JAM,.50 NC,SAE 2,ZINC
180 1 1627408002 SPRING,COMP, 1.9D,05.0L,18.7RT
190 1 2014600064 PLATE,COVER,VALVE,INLET
200 6 2025501259 SCREW,CAP,CS,HEX ,PL.38NCX1.50

46  - QSI 245i/300i
Air Filter - 2011015002
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2013400357 FILTER,AIR,8.0 POWERCORE
20 1 2013200121 CLAMP,HOSE,4.50,4.06 MIN/5.00
30 12 2010356474 SCREW,TAP,CS,WASH,ZN.25NCX0.50
40 1 2014702768 NIPPLE,SCH40,TOE,ZNC,350X03.00
50 1 2013200280 HOSE-FT,INTAKE,AIR,FLEX,6ID
60 1 2013305496 PANEL,FILTER,INLET
70 1 2014701396 FIT R,ELBOW,550X400X90
80 2 2025500920 NUT,FLG,.31 NC,SAE 2,ZINC
90 1 2013305495 AY,PANEL,FILTER,SIDE
100 1 2013301191 BAND,MOUNTING,FILTER, 7.75 ID
110 3 1627432000 CLAMP,HOSE,6.00,5.56 MIN/6.50
120 1 2013305504 SUPPORT,FILTER,AIR
130 2 2014700069 SCREW,CAP,WHIZLOCK,5/16-18X.75
 GRADE 5 (@ 23 FT-LBS)
COMPONENT MAINTENANCE PARTS
 A 1 2013400360 ELEM,FLTR,AIR, 8.0,POWERCORE
 
 * ITEM 110: QUANTITY OF ONE (1) ON UNITS LESS CABINET.
 ** ITEM 50: NOT USED ON UNITS LESS CABINET.
@ INDICATES TORQUE VALUE IN FOOT POUNDS (LUBRICATED THREADS).
REVISED ITEM 9 PART NUMBER (08/12/09).
 - QSI 245i/300i 47
Air Filter - 2011015003
UPDATED PER DESIGN CHANGES (09/18/07).
48  - QSI 245i/300i
Air Filter - 2011015003
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2013305496 PANEL,FILTER,INLET
20 12 2010356474 SCREW,TAP,CS,WASH,ZN.25NCX0.50
30 1 2014701396 FIT R,ELBOW,550X400X90
40 1 2013305495 AY,PANEL,FILTER,SIDE
50 2 2025500920 NUT,FLG,.31 NC,SAE 2,ZINC
60 1 1627432000 CLAMP,HOSE,6.00,5.56 MIN/6.50
70 1 2014702768 NIPPLE,SCH40,TOE,ZNC,350X03.00
80 1 2013301191 BAND,MOUNTING,FILTER, 7.75 ID
90 2 2014700069 SCREW,CAP,WHIZLOCK,5/16-18X.75
 GRADE 5 (@ 23 FT-LBS)
100 1 2013200121 CLAMP,HOSE,4.50,4.06 MIN/5.00
110 1 2013400357 FILTER,AIR,8.0 POWERCORE
120 1 2013305504 SUPPORT,FILTER,AIR
COMPONENT MAINTENANCE PARTS
 A 1 2013400360 ELEM,FLTR,AIR, 8.0,POWERCORE
 * ITEM 60: QUANTITY OF ONE (1) ON UNITS LESS CABINET.
@ INDICATES TORQUE VALUE IN FOOT POUNDS (LUBRICATED THREADS).
UPDATED PER DESIGN CHANGES (09/18/07).
 - QSI 245i/300i 49
Reservoir - 2011018428
UPDATED PER DESIGN CHANGES (09/18/07).
50  - QSI 245i/300i
Reservoir - 2011018428
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 2 2010356458 O-RING,VITON--,0.19W, 9.75ID
20 1 2014701159 FIT T,ELBOW,ORNG,075MSX075FSX9
30 2 2014700368 NUT,LOK,.31 NC,SAE 2,ZINC
40 1 2014700654 O-RING,VITON--,0.09W, 0.56ID
50 1 2013402056 SEPARATOR
60 1 2013900362 VALVE,RELIEF,050P,200PSI,ANC
70 1 2014705379 PLUG,O-RING,1-5/8-12,HX HEAD
80 1 1627456103 SIGHTGLASS, 1-7/8-12 UNC
90 3 2014700052 SCREW,LOK,CS,HEX,ZN,M10 X 30
100 1 2013100764 RESERVOIR,A/F,QSI-245I/300I
110 1 2013100502 COVER,PRV,QSI-245I-500I
120 1 2014706480 VALVE,QTRTURN,BALL,050S, 600WP
130 1 2014705355 PLUG,O-RING,1-5/16-12,HX SOCK
140 1 2010356525 PLUG,O-RING,3/4-16,HX SOCK
150 1 2014701342 FIT P,PLUG-,BRASS 025 HX HEAD
160 1 2014704212 U-BOLT,.31NC,ZN,1.50IDX 2.19IL
COMPONENT MAINTENANCE PARTS
 A 1 5533039100 O-RING,VITON--,0.118W,1.475ID
 B 1 5534969600 O-RING,VITON--,0.118W,1.720ID
 C 4 2010356498 O-RING,VITON--,0.087W,0.644ID
 D 1 5533039000 O-RING,VITON--,0.116W,1.171ID

FILME Compressor
Motor Mounting - 2011005043
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 2 1627456018 BLOCK,RISER,3.00X3.00X1.00,.75
20 5 2010356490 SCREW,CAP,CS,HEX ,ZN,M08 X 16
30 8 2025501573 WASHER,HLOK.625CRS,ZN,.156 THK
40 2 2014700090 SCREW,CAP,CS,HEX, ZN,M12 X 65
50 4 2010356608 SCREW,LOK,CS,HEX,ZN,M12 X 25
60 2 2010336172 WASHER,FLAT .75 CRS,PL.125 THK
70 6 2013304351 SEAL-FT,RUBBER,ADH,.50X.25THK
80 1 2013305507 PANEL,AIR DAM,ODP
90 8 2010356550 SCREW,CAP,CS,HEX ,ZN.62NCX1.75
100 2 2013305460 ISOLATOR,VIBRAT,1100LB,WHT DT
110 2 2025501571 WASHER,HLOC.500CRS,ZN,.125 THK
120 1 2013305583 PANEL,MTR,PAN,50HP,ODP,326TSC
 * SEE DRAWING NOTES FOR USAGE SPECIFICATIONS.
52  - QSI 245i/300i
Motor Mounting - 2011005044
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2013305507 PANEL,AIR DAM,ODP
20 2 2010356595 SCREW,CAP,CS,HEX ,ZN,M12 X40
30 8 2025501573 WASHER,HLOK.625CRS,ZN,.156
40 2 2013305460 ISOLATOR,VIBRAT,1100LB,WHT
50 2 2025501571 WASHER,HLOC.500CRS,ZN,.125
60 1 2010336172 WASHER,FLAT .75 CRS,PL.125
70 5 2010356490 SCREW,CAP,CS,HEX ,ZN,M08 X16
80 8 2010356550 SCREW,CAP,CS,HEX ,ZN.62NCX1.75
90 4 2010356608 SCREW,LOK,CS,HEX,ZN,M12 X 25
100 6 2013304351 SEAL-FT,RUBBER,ADH,.50X.25THK
110 1 2013305582 PANEL,MTR,PAN,60HP,ODP,364TSC
 * SEE DRAWING NOTES FOR USAGE SPECIFICATIONS.
 - QSI 245i/300i 53
Motor Mounting - 2011005045
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 5 2010356490 SCREW,CAP,CS,HEX ,ZN,M08 X 16
20 2 2010336172 WASHER,FLAT .75 CRS,PL.125 THK
30 8 2025501573 WASHER,HLOK.625CRS,ZN,.156 THK
40 2 2025501571 WASHER,HLOC.500CRS,ZN,.125 THK
50 1 2013305506 PANEL,AIR DAM,TEFC
60 8 2010356550 SCREW,CAP,CS,HEX ,ZN.62NCX1.75
70 2 1627456018 BLOCK,RISER,3.00X3.00X1.00,.75
80 2 2013305460 ISOLATOR,VIBRAT,1100LB,WHT DT
90 2 2014700090 SCREW,CAP,CS,HEX, ZN,M12 X 65
100 4 2010356608 SCREW,LOK,CS,HEX,ZN,M12 X 25
 * SEE DRAWING NOTES FOR USAGE SPECIFICATIONS.
54  - QSI 245i/300i
Motor Mounting - 2011005046
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 2 2013305460 ISOLATOR,VIBRAT,1100LB,WHT DT
20 1 2010336172 WASHER,FLAT .75 CRS,PL.125 THK
30 8 2010356550 SCREW,CAP,CS,HEX ,ZN.62NCX1.75
40 2 2010356595 SCREW,CAP,CS,HEX ,ZN,M12 X 40
50 1 2013305506 PANEL,AIR DAM,TEFC
60 8 2025501573 WASHER,HLOK.625CRS,ZN,.156 THK
70 5 2010356490 SCREW,CAP,CS,HEX ,ZN,M08 X 16
80 4 2010356608 SCREW,LOK,CS,HEX,ZN,M12 X 25
90 2 2025501571 WASHER,HLOC.500CRS,ZN,.125 THK
 * SEE DRAWING NOTES FOR USAGE SPECIFICATIONS.
 - QSI 245i/300i 55
Motor Mounting - 2011005047
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 2 1627456018 BLOCK,RISER,3.00X3.00X1.00,.75
20 2 2014700090 SCREW,CAP,CS,HEX, ZN,M12 X 65
30 2 2013305460 ISOLATOR,VIBRAT,1100LB,WHT DT
40 2 2025501571 WASHER,HLOC.500CRS,ZN,.125 THK
50 4 2010356608 SCREW,LOK,CS,HEX,ZN,M12 X 25
60 2 2010336172 WASHER,FLAT .75 CRS,PL.125 THK
70 8 2025501573 WASHER,HLOK.625CRS,ZN,.156 THK
80 8 2010356550 SCREW,CAP,CS,HEX,ZN.62NCX1.75
 * SEE DRAWING NOTES FOR USAGE SPECIFICATIONS.
56  - QSI 245i/300i
Motor Mounting - 2011005048
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 8 2010356550 SCREW,CAP,CS,HEX ,ZN.62NCX1.75
20 2 2025501571 WASHER,HLOC.500CRS,ZN,.125 THK
30 8 2025501573 WASHER,HLOK.625CRS,ZN,.156 THK
40 4 2010356608 SCREW,LOK,CS,HEX,ZN,M12 X 25
50 2 2013305460 ISOLATOR,VIBRAT,1100LB,WHT DT
60 1 2010336172 WASHER,FLAT .75 CRS,PL.125 THK
70 2 2010356595 SCREW,CAP,CS,HEX ,ZN,M12 X 40
 * SEE DRAWING NOTES FOR USAGE SPECIFICATIONS.
 - QSI 245i/300i 57
Airend Mounting - 2011005082
58  - QSI 245i/300i
Airend Mounting - 2011005082
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 2 2010356595 SCREW,CAP,CS,HEX ,ZN,M12 X 40
20 2 2010336172 WASHER,FLAT .75 CRS,PL.125 THK
30 2 2025501571 WASHER,HLOC.500CRS,ZN,.125 THK
40 1 2014001383 STRAP,GROUND,FRAME,13.00LG
50 1 2013305638 SUPPORT,AIREND,QSI-245I/300I
60 2 2014700002 SCREW,CAP,CS,HEX,ZN,RED,M10X50
70 2 2014700001 SCREW,CAP,CS,HEX,ZN,RED,M10X25
80 4 2010356608 SCREW,LOK,CS,HEX,ZN,M12 X 25
90 2 2025501530 WASHER,FLAT.500HRS,ZN,.109 THK
100 2 2014700356 NUT,HEX, 10 N_,_____,ZINC
110 2 2013305460 ISOLATOR,VIBRAT,1100LB,WHT DT
 
 * SEE DRAWING NOTES FOR USAGE SPECIFICATIONS.
 - QSI 245i/300i 59
Cooler (Air-cooled) - 2011015747
60  - QSI 245i/300i
Cooler (Air-cooled) - 2011015747
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2013305544 AY,SUPPORT,COOLER (0.1875 CRS
20 1 2013305546 PANEL,BRACE,COOLER(0.1875 CRS
30 2 2013305606 PANEL,SIDE,SHROUD,FAN
40 1 2013305763 PLATE,COVER,FAN HOUSING
50 1 2013305816 PANEL,BOTTOM,SHROUD,COOLER
60 1 2025500080 FIT C,BLANK,NEMA-1,150
70 1 2013305811 PANEL,MOTOR,SHROUD,FAN
80 6 2025500997 NUT,SPD,.25 NC,STEEL,ZINC,GRIP
90 4 2013304351 SEAL-FT,RUBBER,ADH,.50X.25THK
100 16 2014700069 SCREW,CAP,WHIZLOCK,5/16-18X.75
110 16 2025500920 NUT,FLG,.31 NC,SAE 2,ZINC
120 8 2014702047 WASHER,FEND .250 HRS,ZN,062THK
130 4 2010356477 SCREW,CAP,WHIZLOCK,1/2-13X1.00
140 18 2010356492 SCREW,CAP,CS,HEX ,ZN,M08 X 25
150 4 2010356478 SCREW,TAP,CS,WASH,ZN.25NCX1.00
160 50 2010356474 SCREW,TAP,CS,WASH,ZN.25NCX0.50
170 1 2013500724 COOLER,FLD,QSI-245I/300I
180 1 2013600278 GUARD,FAN,QSI-245I/300I
190 1 2013600287 WHEEL,FAN,18”,100%CW,BC,50/60I
200 1 2013305588 PANEL,ACCESS,SHROUD,COOLER
210 1 2013305815 PANEL,TOP,SHROUD,COOLER,L/CAB
220 6 2025501202 SCREW,CAP,CS,WASH,ZN.25NCX0.75
230 1 2013300145 PANEL,END,SHROUD,COOLER
240 1 2013305812 PANEL,MOTOR,STIFFENER,FAN
250 1 2013500723 COOLER,AFT,QSI-245I/300I
260 1 2013305818 PANEL,SIDE,SHROUD,COOLER
270 1 2013600268 CONE,FAN,18”,REDU,245I/300I
280 1 2013305510 AY,SUPPORT,COOLER (0.1875 CRS)
290 1 2013305813 PANEL,VENTURI,SHROUD,FAN
 

 - QSI 245i/300i 61
Cooler (Air-cooled) - 2011015748
62  - QSI 245i/300i
Cooler (Air-cooled) - 2011015748
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2013305588 PANEL,ACCESS,SHROUD,COOLER
20 4 2013304351 SEAL-FT,RUBBER,ADH,.50X.25THK
30 16 2025500920 NUT,FLG,.31 NC,SAE 2,ZINC
40 1 2013305818 PANEL,SIDE,SHROUD,COOLER
50 1 2013600287 WHEEL,FAN,18”,100%CW,BC,50/60I
60 1 2013305544 AY,SUPPORT,COOLER (0.1875 CRS)
70 1 2013305812 PANEL,MOTOR,STIFFENER,FAN
80 1 2013305763 PLATE,COVER,FAN HOUSING
90 1 2013305510 AY,SUPPORT,COOLER (0.1875 CRS)
100 6 2025501202 SCREW,CAP,CS,WASH,ZN.25NCX0.75
110 6 2025500997 NUT,SPD,.25 NC,STEEL,ZINC,GRIP
120 4 2010356478 SCREW,TAP,CS,WASH,ZN.25NCX1.00
130 1 2013300145 PANEL,END,SHROUD,COOLER
140 1 2013500723 COOLER,AFT,QSI-245I/300I
150 8 2014702047 WASHER,FEND .250 HRS,ZN,062THK
160 1 2013305813 PANEL,VENTURI,SHROUD,FAN
170 50 2010356474 SCREW,TAP,CS,WASH,ZN.25NCX0.50
180 1 2013305811 PANEL,MOTOR,SHROUD,FAN
190 2 2013305606 PANEL,SIDE,SHROUD,FAN
200 1 2013305816 PANEL,BOTTOM,SHROUD,COOLER
210 16 2014700069 SCREW,CAP,WHIZLOCK,5/16-18X.75
220 1 2013305546 PANEL,BRACE,COOLER(0.1875 CRS)
230 1 2013500724 COOLER,FLD,QSI-245I/300I
240 1 2013305817 PANEL,TOP,SHROUD,COOLER,W/CAB
250 1 2025500080 FIT C,BLANK,NEMA-1,150
260 18 2010356492 SCREW,CAP,CS,HEX ,ZN,M08 X 25
270 4 2010356477 SCREW,CAP,WHIZLOCK,1/2-13X1.00
280 1 2013600268 CONE,FAN,18”,REDU,245I/300I
 

 - QSI 245i/300i 63
Air Piping (Air-cooled, with dryer) - 2011014795
64  - QSI 245i/300i
Air Piping (Air-cooled, with dryer) - 2011014795
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2013800430 TRAP,MOISTURE,1-1/2”NPT,EVOLUT
20 2 2014701863 FIT T,CONEC,PRFL,150ST,O-RING
30 1 2014702234 NIPPLE,BRASS,TBE, XS,025X01.25
40 4 2014700381 NUT,HEXFLG,.25 NC,SAE 2,ZINC
50 2 2025500367 FIT P,CPLG,150GLV 125X125
60 1 2014702295 NIPPLE,SCH40,TBE,GLV 125X11.50
70 1 2014701445 FIT T,CONEC,37FL,150STX125MP
80 1 2023912906 VALVE,QTRTURN,BALL,125P, 600WP
90 1 2014701752 FIT P,CPLG,BRASS, 012X012
100 1 2014702207 NIPPLE,SCH80,TBE,SST,150X02.00
110 1 2013305616 BRACKET,PIPE,AIR
120 2 2014702286 NIPPLE,SCH40,TBE,GLV 125X06.00
130 1 2013305615 BRACKET,PIPE,AIR
140 1 2014701271 FIT P,BUSHG,BRASS, 050X025 HEX
150 1 2014701913 FIT T,CONEC,FLLS,038NTX025MP
160 2 2014701305 FIT P,CPLG,BRASS,025X025BLKHD
170 2 2014702281 NIPPLE,SCH40,TBE,GLV 125X04.00
180 1 2013201901 AY,TUBE,3B,PRFLG,1.50
190 2 2014701259 FIT P,ELBOW,150GLV 125X125X90
200 1 2014701904 FIT T,CONEC,FLLS,025NTX012MP
210 1 2014701004 FIT P,BUSHG,BRASS,075X050HEX
220 4 2025501119 SCREW,TAP,CS,WASH,ZN.25NCX0.75
230 1 2014701665 FIT T,ELBOW,FLLS,038NTX025MPX9
240 1 2013900027 VALVE,DRAIN,025P,24VAC,50/60
250 4 2013200834 CLAMP,TUBE,1.66ID
260 1 2013900223 VALVE,CHK,MIN PRS,1.88S,60,160
270 5 2014704993 TUBE-FT,1/4 NYLON,CLEAR
280 4 2014700108 SCREW,CAP,CS,HEX ,ZN.25NCX3.00
290 1 2014701152 FIT P,UNION,ORNG,PLN,M188X188
300 1 2014701663 FIT T,ELBOW,FLLS,025NTX025MPX9
310 2 2013200844 PLATE,COVER,CLAMP,TUBE,1.38ID
320 5 2014704994 TUBE-FT,3/8 NYLON,CLEAR
330 1 1624505821 AY,FLTR,COALSEC,STD,01.25NPT
340 2 1627431011 AY,HOSEF1.50 45.00 500WP
350 1 2014701451 FIT T,ELBOW,37FL,150STX150MPX9
360 1 1627441144 AY,CABLE,DIN CONN.,7 METER
COMPONENT MAINTENANCE PARTS
 A 1 1627456072 KT,REPAIR,FOR 128691-001
 B 4 5534969600 O-RING,VITON--,0.118W,1.720ID
 C 4 2010356512 O-RING,VITON--,0.07W,1.49ID,PF
 D 1 2010345125 ELEMENT,FLTR,COALS,STD,00300

UPDATED PER DESIGN CHANGES (08/06/07).
 - QSI 245i/300i 65
Air Piping (water-cooled, less dryer) - 2011014802
66  - QSI 245i/300i
Air Piping (water-cooled, less dryer) - 2011014802
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2013900223 VALVE,CHK,MIN PRS,1.88S,60,160
20 2 2014701007 FIT P,ELBOW,150GLV 150X150X90
30 2 2013200844 PLATE,COVER,CLAMP,TUBE,1.38ID
40 1 2014701004 FIT P,BUSHG,BRASS, 075X050 HEX
50 1 2014702234 NIPPLE,BRASS,TBE, XS,025X01.25
60 3 2014701847 FIT T,CONEC,PRFL,150ST,150NPTF
70 1 2014701305 FIT P,CPLG,BRASS,025X025BLKHD
80 1 2013305311 SUPPORT,PIPING,QSI-I/QGV,WC
90 1 2013800430 TRAP,MOISTURE,1-1/2”NPT,EVOLUT
100 4 2014700047 SCREW,LOK,CS,HEX,ZN,M08 X 20
110 1 2013201261 AY,TUBE,2B,SELOC,1.50,23X37X11
120 4 2014700108 SCREW,CAP,CS,HEX ,ZN.25NCX3.00
130 1 2013201902 AY,TUBE,3B,PRFLG,1.50
140 1 2014701271 FIT P,BUSHG,BRASS, 050X025 HEX
150 1 2013305309 AY,SUPPORT,PIPING,QSI-I/QGV
160 1 2014702327 NIPPLE,SCH40,TBE,GLV,150X07.50
170 1 2013900027 VALVE,DRAIN,025P,24VAC,50/60
180 4 2014700381 NUT,HEXFLG,.25 NC,SAE 2,ZINC
190 1 2014701863 FIT T,CONEC,PRFL,150ST,O-RING
200 1 2013500503 HEATXCHNGR,AFTCLR,WC
210 1 2025500326 FIT P,TEE--,150GLV 150X050X150
220 1 2014701663 FIT T,ELBOW,FLLS,025NTX025MPX9
230 1 2014702684 NIPPLE,SCH40,TBE,GLV,150X03.25
240 1 2023907900 DRAIN,MANUAL,8-80GAL.1/4 NPT
250 2 2013200832 CLAMP,TUBE,1.38ID
260 1 2014701945 FIT T,CONEC,FLLS,025NTX025MP
270 5 2014705166 TUBE-FT,1/4 NYLON 11,BLACK
280 1 2014701152 FIT P,UNION,ORNG,PLN,M188X188
290 1 2014702328 NIPPLE,SCH40,TBE,GLV,150X08.25
300 1 1627441144 AY,CABLE,DIN CONN.,7 METER
COMPONENT MAINTENANCE PARTS
2013500503 AFTERCOOLER:
 A 1 2013500507 BONNET,IN/OUT END
 B 1 2013306164 GASKET,IN/OUT END
 C 1 2013500508 BONNET,RETURN END
 D 1 2013306154 GASKET,IN/OUT END 2P,RETURN 4P
124061-001 & 127267-2 AFTERCOOLER: 
 A 1 2013301417 BONNET,IN/OUT END
 B 1 2013306162 GASKET,IN/OUT END
 C 1 2013301418 BONNET,RETURN END
 D 1 2013306163 GASKET,RETURN
OTHER COMPONENTS:
 E 3 5534969600 O-RING,VITON--,0.118W,1.720ID
 F 4 2010356512 O-RING,VITON--,0.07W,1.49ID,PF
 G 1 2014700609 O-RING,MOISTURE TRAP

 - QSI 245i/300i 67
Air Piping (water-cooled, with drye) - 2011014803
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 1627431011 AY,HOSEF1.50 45.00 500WP
20 1 2013900223 VALVE,CHK,MIN PRS,1.88S,60,160
30 1 2014701847 FIT T,CONEC,PRFL,150ST,150NPTF
40 1 1627431007 AY,HOSEF1.50 63.75 500WP
50 1 2023912906 VALVE,QTRTURN,BALL,125P, 600WP
60 2014704993 TUBE-FT,1/4 NYLON,CLEAR
70 1 2014702315 NIPPLE,SCH40,TBE,GLV,150X02.00
80 2 2014702234 NIPPLE,BRASS,TBE, XS,025X01.25
90 1 2013900027 VALVE,DRAIN,025P,24VAC,50/60
100 2 2014701305 FIT P,CPLG,BRASS,025X025BLKHD
110 2 2013200844 PLATE,COVER,CLAMP,TUBE,1.38ID
68  - QSI 245i/300i
Air Piping (water-cooled, with drye) - 2011014803
ITEM NO. QTY. PART NUMBER DESCRIPTION
120 4 2014700108 SCREW,CAP,CS,HEX ,ZN.25NCX3.00
130 1 2014701444 FIT T,CONEC,37FL,150STX150MP
140 1 1624505821 AY,FLTR,COALSEC,STD,01.25NPT
150 1 2014701904 FIT T,CONEC,FLLS,025NTX012MP
160 2 2013305617 BRACKET,PIPE,AIR
170 1 2013500503 HEATXCHNGR,AFTCLR,WC
180 1 2013201902 AY,TUBE,3B,PRFLG,1.50
190 2 2014701007 FIT P,ELBOW,150GLV 150X150X90
200 2 2025500367 FIT P,CPLG,150GLV 125X125
210 1 2014701913 FIT T,CONEC,FLLS,038NTX025MP
220 2 2014702281 NIPPLE,SCH40,TBE,GLV 125X04.00
230 1 2014702295 NIPPLE,SCH40,TBE,GLV 125X11.50
240 1 2014701663 FIT T,ELBOW,FLLS,025NTX025MPX9
250 1 2014701004 FIT P,BUSHG,BRASS, 075X050 HEX
260 1 2014701271 FIT P,BUSHG,BRASS, 050X025 HEX
270 2 2014702286 NIPPLE,SCH40,TBE,GLV 125X06.00
280 1 2014701863 FIT T,CONEC,PRFL,150ST,O-RING
290 1 2014701665 FIT T,ELBOW,FLLS,038NTX025MPX9
300 1 2014701445 FIT T,CONEC,37FL,150STX125MP
310 5 2014704994 TUBE-FT,3/8 NYLON,CLEAR
320 1 2010338110 FIT P,UNION,150GLV 150X150
330 2 2014701259 FIT P,ELBOW,150GLV 125X125X90
340 1 2013800430 TRAP,MOISTURE,1-1/2”NPT,EVOLUT
350 4 2013200834 CLAMP,TUBE,1.66ID
360 3 2014702684 NIPPLE,SCH40,TBE,GLV,150X03.25
370 4 2014700069 SCREW,CAP,WHIZLOCK,5/16-18X.75
380 1 2014701152 FIT P,UNION,ORNG,PLN,M188X188
390 4 2014700381 NUT,HEXFLG,.25 NC,SAE 2,ZINC
400 4 2025501119 SCREW,TAP,CS,WASH,ZN.25NCX0.75
410 4 2025500920 NUT,FLG,.31 NC,SAE 2,ZINC
420 1 2014701752 FIT P,CPLG,BRASS, 012X012
430 1 1627441144 AY,CABLE,DIN CONN.,7 METER
COMPONENT MAINTENANCE PARTS
2013500503 AFTERCOOLER:
 A 1 2013500507 BONNET,IN/OUT END
 B 1 2013306164 GASKET,IN/OUT END
 C 1 2013500508 BONNET,RETURN END
 D 1 2013306154 GASKET,IN/OUT END 2P,RETURN 4P
124061-001 & 127267-2 AFTERCOOLER: 
 A 1 2013301417 BONNET,IN/OUT END
 B 1 2013306162 GASKET,IN/OUT END
 C 1 2013301418 BONNET,RETURN END
 D 1 2013306163 GASKET,RETURN END
OTHER COMPONENTS:
 E 3 5534969600 O-RING,VITON--,0.118W,1.720ID
 F 4 2010356512 O-RING,VITON--,0.07W,1.49ID,PF
 G 1 2014700609 O-RING,MOISTURE TRAP
 H 1 2014700609 O-RING,VITON
 J 1 CSN E00300 FILTER ELEMENT

 - QSI 245i/300i 69
Fluid Piping (air-cooled, less fluid pump) - 2011014792
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 2 2014701795 FIT T,ELBOW,PRFL,100ST O-RING
20 1 1627410022 HEAD,FILTER,FLD,162SAE,REM-IND
30 2 2014701798 FIT T,ELBOW,PRFL,125ST O-RING
40 1 2013201271 AY,HOSE,0.88X49,STR X 90
50 1 2014701150 FIT P,UNION,ORNG,PLN,M131X131
60 1 2014701936 FIT T,TEE,RN,PRFL,100ST,O-RING
70 1 2013305796 SUPPORT,FILTER,FLUID
80 1 2014700073 SCREW,CAP,WHIZLOCK,5/8-11X1.00
90 1 2013201247 AY,TUBE,0B,PRFLG,1.25,15
100 2 2014701858 FIT T,CONEC,PRFL,100ST,O-RING
110 1 2013201270 AY,HOSE,0.88X34,STR X 90
120 1 2013900132 VALVE,THERMO,131S,190F,150WP
130 2 2014700069 SCREW,CAP,WHIZLOCK,5/16-18X.75
140 1 2013400282 ELEM,FLTR,FLD,B12
150 1 2014701317 FIT,ADAPTER,O-RING,131FX162M
160 1 2013201274 AY,HOSE,0.88X25,STR X 45
COMPONENT MAINTENANCE PARTS
A 2 2014700526 O-RING,VITON--,0.07W,1.18ID,PF
B 3 5533039100 O-RING,VITON--,0.118W,1.475ID
C 5 2014700526 O-RING,VITON--,0.07W,0.93ID,PF
D 8 5533039000 O-RING,VITON--,0.116W,1.171ID
E 1 1627456034 KT,VALVE,THERMO,190F
 1 2013900139 ELEMENT,VALVE,THERMO,190F
 1 2013900135 SEAL,VALVE,THERMO
 1 1627413017 GASKET/O-RING,VALVE,THERMO
70  - QSI 245i/300i
Fluid Piping (air-cooled, less fluid pump) - 2011014793

120
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2013305796 SUPPORT,FILTER,FLUID
20 1 1627410022 HEAD,FILTER,FLD,162SAE,REM-IND
30 2 2014700069 SCREW,CAP,WHIZLOCK,5/16-18X.75
40 1 2013201274 AY,HOSE,0.88X25,STR X 45
50 1 2013201271 AY,HOSE,0.88X49,STR X 90
60 1 2014701936 FIT T,TEE,RN,PRFL,100ST,O-RING
70 1 2013201193 AY,HOSE,1.00X16,STR X STR
80 4 2014701858 FIT T,CONEC,PRFL,100ST,O-RING
90 2 2014701795 FIT T,ELBOW,PRFL,100ST O-RING
100 2 2014701798 FIT T,ELBOW,PRFL,125ST O-RING
110 1 2014700073 SCREW,CAP,WHIZLOCK,5/8-11X1.00
120 1 2013400282 ELEM,FLTR,FLD,B12
130 1 2013201270 AY,HOSE,0.88X34,STR X 90
140 1 2014701150 FIT P,UNION,ORNG,PLN,M131X131
150 1 2013201247 AY,TUBE,0B,PRFLG,1.25,15
160 3 2014701317 FIT,ADAPTER,O-RING,131FX162M
170 1 2013900132 VALVE,THERMO,131S,190F,150WP
COMPONENT MAINTENANCE PARTS
A 2 2014700526 O-RING,VITON--,0.07W,1.18ID,PF
B 3 5533039100 O-RING,VITON--,0.118W,1.475ID
C 5 2014700526 O-RING,VITON--,0.07W,0.93ID,PF
D 8 5533039000 O-RING,VITON--,0.116W,1.171ID
E 1 1627456034 KT,VALVE,THERMO,190F
 1 2013900139 ELEMENT,VALVE,THERMO,190F
 1 2013900135 SEAL,VALVE,THERMO
 1 1627413017 GASKET/O-RING,VALVE,THERMO
 - QSI 245i/300i 71
Fluid Piping (water-cooled,less fluid pump) - 2011014810
72  - QSI 245i/300i
Fluid Piping (water-cooled,less fluid pump) - 2011014810
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2013500475 HEATXCHNGR,FLDCLR,WC
20 1 2013305493 SUPPORT,COOLER,FLUID
30 3 2014701858 FIT T,CONEC,PRFL,100ST,O-RING
40 1 2014701317 FIT,ADAPTER,O-RING,131FX162M
50 6 2014700052 SCREW,LOK,CS,HEX,ZN,M10 X 30
60 1 2014701795 FIT T,ELBOW,PRFL,100ST O-RING
70 1 2013201247 AY,TUBE,0B,PRFLG,1.25,15
80 2 2013201270 AY,HOSE,0.88X34,STR X 90
90 2 2013305144 BRACKET,SUPPORT,COOLER,FLUID
100 1 2014701936 FIT T,TEE,RN,PRFL,100ST,O-RING
110 8 2010356474 SCREW,TAP,CS,WASH,ZN.25NCX0.50
120 4 2025500920 NUT,FLG,.31 NC,SAE 2,ZINC
130 1 2014701150 FIT P,UNION,ORNG,PLN,M131X131
140 1 1627410022 HEAD,FILTER,FLD,162SAE,REM-IND
150 1 2013201251 AY,TUBE,2B,PRFLG,1.00,5X13X12
160 1 2013305796 SUPPORT,FILTER,FLUID
170 2 2014701798 FIT T,ELBOW,PRFL,125ST O-RING
180 6 2014700069 SCREW,CAP,WHIZLOCK,5/16-18X.75
190 1 2014700073 SCREW,CAP,WHIZLOCK,5/8-11X1.00
200 1 2013900132 VALVE,THERMO,131S,190F,150WP
210 1 2013400282 ELEM,FLTR,FLD,B12
COMPONENT MAINTENANCE PARTS
2013500475 HEATXCHNGR,FLDCLR,WC: 
 A 1 2013500507 BONNET,IN/OUT END
 B 1 2013306164 GASKET,IN/OUT END
 C 1 2013500508 BONNET,RETURN END
 D 1 2013306154 GASKET,IN/OUT 2P,RETURN END 4P
2013500087 & 2013500175 HEATXCHNGR,FLDCLR,SEA WTR & 
 HEATXCHNGR,FLDCLR,STN STL : 
 A 1 COOLER BONNET-IN/OUT END
 B 1 COOLER GASKET-IN/OUT END
 C 1 COOLER BONNET-RETURN END
 D 1 COOLER GASKET-RETURN END
OTHER COMPONENTS: 
 E 8 5533039000 O-RING,VITON--,0.116W,1.171ID
 F 1 1627456034 KT,VALVE,THERMO,190F
 2013900139 ELEMENT,VALVE,THERMO,190F
 2013900135 SEAL,VALVE,THERMO
 1627413017 GASKET/O-RING,VALVE,THERMO
 G 5 2014700526 O-RING,VITON--,0.07W,0.93ID,PF
 H 3 5533039100 O-RING,VITON--,0.118W,1.475ID 
 J 2 2014700526 O-RING,VITON--,0.07W,1.18ID,PF

 - QSI 245i/300i 73
Fluid Piping (water-cooled,less fluid pump) - 2011014812
74  - QSI 245i/300i
Fluid Piping (water-cooled,less fluid pump) - 2011014812
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2013900132 VALVE,THERMO,131S,190F,150WP
20 3 2014701858 FIT T,CONEC,PRFL,100ST,O-RING
30 1 2014701795 FIT T,ELBOW,PRFL,100ST O-RING
40 1 2013201247 AY,TUBE,0B,PRFLG,1.25,15
50 6 2014700052 SCREW,LOK,CS,HEX,ZN,M10 X 30
60 1 1627410022 HEAD,FILTER,FLD,162SAE,REM-IND
70 1 2014701936 FIT T,TEE,RN,PRFL,100ST,O-RING
80 1 2013305796 SUPPORT,FILTER,FLUID
90 2 2013201270 AY,HOSE,0.88X34,STR X 90
100 2 2013305144 BRACKET,SUPPORT,COOLER,FLUID
110 1 2013201251 AY,TUBE,2B,PRFLG,1.00,5X13X12
120 8 2010356474 SCREW,TAP,CS,WASH,ZN.25NCX0.50
130 6 2014700069 SCREW,CAP,WHIZLOCK,5/16-18X.75
140 4 2025500920 NUT,FLG,.31 NC,SAE 2,ZINC
150 1 2014700073 SCREW,CAP,WHIZLOCK,5/8-11X1.00
160 1 2014701317 FIT,ADAPTER,O-RING,131FX162M
170 1 2013500087 HEATXCHNGR,FLDCLR,SEA WTR
180 1 2013400282 ELEM,FLTR,FLD,B12
190 1 2013305493 SUPPORT,COOLER,FLUID
200 2 2014701798 FIT T,ELBOW,PRFL,125ST O-RING
210 1 2014701150 FIT P,UNION,ORNG,PLN,M131X131
COMPONENT MAINTENANCE PARTS
2013500475 HEATXCHNGR,FLDCLR,WC: 
 A 1 2013500507 BONNET,IN/OUT END
 B 1 2013306164 GASKET,IN/OUT END
 C 1 2013500508 BONNET,RETURN END
 D 1 2013306154 GASKET,IN/OUT 2P,RETURN END 4P
2013500087 & 2013500175 HEATXCHNGR,FLDCLR,SEA WTR & 
 HEATXCHNGR,FLDCLR,STN STL : 
 A 1 COOLER BONNET-IN/OUT END
 B 1 COOLER GASKET-IN/OUT END
 C 1 COOLER BONNET-RETURN END
 D 1 COOLER GASKET-RETURN END
OTHER COMPONENTS: 
 E 8 5533039000 O-RING,VITON--,0.116W,1.171ID
 F 1 1627456034 KT,VALVE,THERMO,190F
 2013900139 ELEMENT,VALVE,THERMO,190F
 2013900135 SEAL,VALVE,THERMO
 1627413017 GASKET/O-RING,VALVE,THERMO
 G 5 2014700526 O-RING,VITON--,0.07W,0.93ID,PF
 H 3 5533039100 O-RING,VITON--,0.118W,1.475ID 
 J 2 2014700526 O-RING,VITON--,0.07W,1.18ID,PF

 - QSI 245i/300i 75
Fluid Piping (water-cooled,less fluid pump) - 2011014814
76  - QSI 245i/300i
Fluid Piping (water-cooled,less fluid pump) - 2011014814
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2014701150 FIT P,UNION,ORNG,PLN,M131X131
20 1 2014701936 FIT T,TEE,RN,PRFL,100ST,O-RING
30 1 2013305493 SUPPORT,COOLER,FLUID
40 1 2013900132 VALVE,THERMO,131S,190F,150WP
50 6 2014700052 SCREW,LOK,CS,HEX,ZN,M10 X 30
60 1 2013305796 SUPPORT,FILTER,FLUID
70 3 2014701858 FIT T,CONEC,PRFL,100ST,O-RING
80 1 1627410022 HEAD,FILTER,FLD,162SAE,REM-IND
90 1 2014700073 SCREW,CAP,WHIZLOCK,5/8-11X1.00
100 1 2013201247 AY,TUBE,0B,PRFLG,1.25,15
110 2 2014701798 FIT T,ELBOW,PRFL,125ST O-RING
120 1 2013400282 ELEM,FLTR,FLD,B12
130 6 2014700069 SCREW,CAP,WHIZLOCK,5/16-18X.75
140 2 2013305144 BRACKET,SUPPORT,COOLER,FLUID
150 1 2013201251 AY,TUBE,2B,PRFLG,1.00,5X13X12
160 1 2013500175 HEATXCHNGR,FLDCLR,STN STL
170 8 2010356474 SCREW,TAP,CS,WASH,ZN.25NCX0.50
180 4 2025500920 NUT,FLG,.31 NC,SAE 2,ZINC
190 2 2013201270 AY,HOSE,0.88X34,STR X 90
200 1 2014701317 FIT,ADAPTER,O-RING,131FX162M
210 1 2014701795 FIT T,ELBOW,PRFL,100ST O-RING
COMPONENT MAINTENANCE PARTS
2013500475 HEATXCHNGR,FLDCLR,WC: 
 A 1 2013500507 BONNET,IN/OUT END
 B 1 2013306164 GASKET,IN/OUT END
 C 1 2013500508 BONNET,RETURN END
 D 1 2013306154 GASKET,IN/OUT 2P,RETURN END 4P
2013500087 & 2013500175 HEATXCHNGR,FLDCLR,SEA WTR & 
 HEATXCHNGR,FLDCLR,STN STL : 
 A 1 COOLER BONNET-IN/OUT END
 B 1 COOLER GASKET-IN/OUT END
 C 1 COOLER BONNET-RETURN END
 D 1 COOLER GASKET-RETURN END
OTHER COMPONENTS: 
 E 8 5533039000 O-RING,VITON--,0.116W,1.171ID
 F 1 1627456034 KT,VALVE,THERMO,190F
 2013900139 ELEMENT,VALVE,THERMO,190F
 2013900135 SEAL,VALVE,THERMO
 1627413017 GASKET/O-RING,VALVE,THERMO
 G 5 2014700526 O-RING,VITON--,0.07W,0.93ID,PF
 H 3 5533039100 O-RING,VITON--,0.118W,1.475ID 
 J 2 2014700526 O-RING,VITON--,0.07W,1.18ID,PF

 - QSI 245i/300i 77
Fluid Piping (water-cooled, with fluid pump) - 2011014811
78  - QSI 245i/300i
Fluid Piping (water-cooled, with fluid pump) - 2011014811
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 2 2013305144 BRACKET,SUPPORT,COOLER,FLUID
20 2 2014701795 FIT T,ELBOW,PRFL,100ST O-RING
30 1 2014700073 SCREW,CAP,WHIZLOCK,5/8-11X1.00
40 1 2013305493 SUPPORT,COOLER,FLUID
50 1 2013400282 ELEM,FLTR,FLD,B12
60 2 2014701317 FIT,ADAPTER,O-RING,131FX162M
70 4 2025500920 NUT,FLG,.31 NC,SAE 2,ZINC
80 5 2014701858 FIT T,CONEC,PRFL,100ST,O-RING
90 1 2013900132 VALVE,THERMO,131S,190F,150WP
100 1 2014701150 FIT P,UNION,ORNG,PLN,M131X131
110 1 2013201247 AY,TUBE,0B,PRFLG,1.25,15
120 1 1627410022 HEAD,FILTER,FLD,162SAE,REM-IND
130 1 2014701936 FIT T,TEE,RN,PRFL,100ST,O-RING
140 8 2010356474 SCREW,TAP,CS,WASH,ZN.25NCX0.50
150 1 2013305796 SUPPORT,FILTER,FLUID
160 2 2014701798 FIT T,ELBOW,PRFL,125ST O-RING
170 1 2013201251 AY,TUBE,2B,PRFLG,1.00,5X13X12
180 1 2013500475 HEATXCHNGR,FLDCLR,WC
190 2 2013201270 AY,HOSE,0.88X34,STR X 90
200 6 2014700069 SCREW,CAP,WHIZLOCK,5/16-18X.75
210 1 2013201193 AY,HOSE,1.00X16,STR X STR
220 6 2014700052 SCREW,LOK,CS,HEX,ZN,M10X30
COMPONENT MAINTENANCE PARTS
2013500475 HEATXCHNGR,FLDCLR,WC: 
 A 1 2013500507 BONNET,IN/OUT END
 B 1 2013306164 GASKET,IN/OUT END
 C 1 2013500508 BONNET,RETURN END
 D 1 2013306154 GASKET,IN/OUT 2P,RETURN END 4P
2013500087 & 2013500175 HEATXCHNGR,FLDCLR,SEA WTR & 
 HEATXCHNGR,FLDCLR,STN STL : 
 A 1 COOLER BONNET-IN/OUT END
 B 1 COOLER GASKET-IN/OUT END
 C 1 COOLER BONNET-RETURN END
 D 1 COOLER GASKET-RETURN END
OTHER COMPONENTS: 
 E 8 5533039000 O-RING,VITON--,0.116W,1.171ID
 F 1 1627456034 KT,VALVE,THERMO,190F
 2013900139 ELEMENT,VALVE,THERMO,190F
 2013900135 SEAL,VALVE,THERMO
 1627413017 GASKET/O-RING,VALVE,THERMO
 G 5 2014700526 O-RING,VITON--,0.07W,0.93ID,PF
 H 3 5533039100 O-RING,VITON--,0.118W,1.475ID 
 J 2 2014700526 O-RING,VITON--,0.07W,1.18ID,PF

 - QSI 245i/300i 79
Fluid Piping (water-cooled, with fluid pump) - 2011014813
80  - QSI 245i/300i
Fluid Piping (water-cooled, with fluid pump) - 2011014813
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 2 2014701317 FIT,ADAPTER,O-RING,131FX162M
20 1 1627410022 HEAD,FILTER,FLD,162SAE,REM-IND
30 1 2014701936 FIT T,TEE,RN,PRFL,100ST,O-RING
40 1 2013900132 VALVE,THERMO,131S,190F,150WP
50 2 2013201270 AY,HOSE,0.88X34,STR X 90
60 1 2013305796 SUPPORT,FILTER,FLUID
70 1 2014701150 FIT P,UNION,ORNG,PLN,M131X131
80 4 2025500920 NUT,FLG,.31 NC,SAE 2,ZINC
90 1 2013201193 AY,HOSE,1.00X16,STR X STR
100 1 2014700073 SCREW,CAP,WHIZLOCK,5/8-11X1.00
110 1 2013400282 ELEM,FLTR,FLD,B12
120 2 2014701798 FIT T,ELBOW,PRFL,125ST O-RING
130 1 2013500087 HEATXCHNGR,FLDCLR,SEA WTR
140 6 2014700052 SCREW,LOK,CS,HEX,ZN,M10 X 30
150 6 2014700069 SCREW,CAP,WHIZLOCK,5/16-18X.75
160 2 2013305144 BRACKET,SUPPORT,COOLER,FLUID
170 1 2013305493 SUPPORT,COOLER,FLUID
180 2 2014701795 FIT T,ELBOW,PRFL,100ST O-RING
190 8 2010356474 SCREW,TAP,CS,WASH,ZN.25NCX0.50
200 1 2013201247 AY,TUBE,0B,PRFLG,1.25,15
210 1 2013201251 AY,TUBE,2B,PRFLG,1.00,5X13X12
220 5 2014701858 FIT T,CONEC,PRFL,100ST,O-RING
COMPONENT MAINTENANCE PARTS
2013500475 HEATXCHNGR,FLDCLR,WC: 
 A 1 2013500507 BONNET,IN/OUT END
 B 1 2013306164 GASKET,IN/OUT END
 C 1 2013500508 BONNET,RETURN END
 D 1 2013306154 GASKET,IN/OUT 2P,RETURN END 4P
2013500087 & 2013500175 HEATXCHNGR,FLDCLR,SEA WTR & 
 HEATXCHNGR,FLDCLR,STN STL : 
 A 1 COOLER BONNET-IN/OUT END
 B 1 COOLER GASKET-IN/OUT END
 C 1 COOLER BONNET-RETURN END
 D 1 COOLER GASKET-RETURN END
OTHER COMPONENTS: 
 E 8 5533039000 O-RING,VITON--,0.116W,1.171ID
 F 1 1627456034 KT,VALVE,THERMO,190F
 2013900139 ELEMENT,VALVE,THERMO,190F
 2013900135 SEAL,VALVE,THERMO
 1627413017 GASKET/O-RING,VALVE,THERMO
 G 5 2014700526 O-RING,VITON--,0.07W,0.93ID,PF
 H 3 5533039100 O-RING,VITON--,0.118W,1.475ID 
 J 2 2014700526 O-RING,VITON--,0.07W,1.18ID,PF

 - QSI 245i/300i 81
Fluid Piping (water-cooled, with fluid pump) - 2011014815
82  - QSI 245i/300i
Fluid Piping (water-cooled, with fluid pump) - 2011014815
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2013201247 AY,TUBE,0B,PRFLG,1.25,15
20 4 2025500920 NUT,FLG,.31 NC,SAE 2,ZINC
30 1 2014700073 SCREW,CAP,WHIZLOCK,5/8-11X1.00
40 1 2013900132 VALVE,THERMO,131S,190F,150WP
50 5 2014701858 FIT T,CONEC,PRFL,100ST,O-RING
60 1 2013201251 AY,TUBE,2B,PRFLG,1.00,5X13X12
70 2 2014701795 FIT T,ELBOW,PRFL,100ST O-RING
80 1 2014701936 FIT T,TEE,RN,PRFL,100ST,O-RING
90 2 2014701317 FIT,ADAPTER,O-RING,131FX162M
100 1 1627410022 HEAD,FILTER,FLD,162SAE,REM-IND
110 6 2014700052 SCREW,LOK,CS,HEX,ZN,M10 X 30
120 1 2013201193 AY,HOSE,1.00X16,STR X STR
130 6 2014700069 SCREW,CAP,WHIZLOCK,5/16-18X.75
140 2 2014701798 FIT T,ELBOW,PRFL,125ST O-RING
150 2 2013305144 BRACKET,SUPPORT,COOLER,FLUID
160 1 2013305493 SUPPORT,COOLER,FLUID
170 1 2013400282 ELEM,FLTR,FLD,B12
180 2 2013201270 AY,HOSE,0.88X34,STR X 90
190 8 2010356474 SCREW,TAP,CS,WASH,ZN.25NCX0.50
200 1 2014701150 FIT P,UNION,ORNG,PLN,M131X131
210 1 2013305796 SUPPORT,FILTER,FLUID
220 1 2013500175 HEATXCHNGR,FLDCLR,STN STL
COMPONENT MAINTENANCE PARTS
2013500475 HEATXCHNGR,FLDCLR,WC: 
 A 1 2013500507 BONNET,IN/OUT END
 B 1 2013306164 GASKET,IN/OUT END
 C 1 2013500508 BONNET,RETURN END
 D 1 2013306154 GASKET,IN/OUT 2P,RETURN END 4P
2013500087 & 2013500175 HEATXCHNGR,FLDCLR,SEA WTR & 
 HEATXCHNGR,FLDCLR,STN STL : 
 A 1 COOLER BONNET-IN/OUT END
 B 1 COOLER GASKET-IN/OUT END
 C 1 COOLER BONNET-RETURN END
 D 1 COOLER GASKET-RETURN END
OTHER COMPONENTS: 
 E 8 5533039000 O-RING,VITON--,0.116W,1.171ID
 F 1 1627456034 KT,VALVE,THERMO,190F
 2013900139 ELEMENT,VALVE,THERMO,190F
 2013900135 SEAL,VALVE,THERMO
 1627413017 GASKET/O-RING,VALVE,THERMO
 G 5 2014700526 O-RING,VITON--,0.07W,0.93ID,PF
 H 3 5533039100 O-RING,VITON--,0.118W,1.475ID 
 J 2 2014700526 O-RING,VITON--,0.07W,1.18ID,PF

 - QSI 245i/300i 83
Water Piping - 2011019820
FILME Compressor
Water Piping - 2011019820
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 2 2013305625 PIPING SUPPORT BRACKET
20 2 2014702539 PIPE NIPPLE-GALVANIZED, 1.00 NPT X 4.00
30 2 2013900694 GLOBE VALVE
40 1 2014701844 CONNECTOR-1.00 NPTF X 1.00 TUBE (O-RING)
50 1 2013201256 FORMED TUBE ASSEMBLY-PAR-FLANGED,
 1.00 O.D. (FRESH WATER)
 1 2013201257 FORMED TUBE ASSEMBLY-PAR-FLANGED,
 1.00 O.D., STAINLESS STEEL (SEA WATER)
60 2 2014701017 PIPE COUPLING-GALVANIZED, 1.00 NPT
 2 2014700816 PIPE COUPLING-STAINLESS STEEL,
 1.00 NPT (SEA WATER)
70 1 2013201254 FORMED TUBE ASSEMBLY-PAR-FLANGED,
 1.00 O.D. (FRESH WATER)
 1 2013201255 FORMED TUBE ASSEMBLY-PAR-FLANGED,
 1.00 O.D., STAINLESS STEEL (SEA WATER)
80 4 2013200829 TUBE CLAMP-0.98 I.D.
90 2 2013200843 TUBE CLAMP COVER PLATE-0.98 I.D.
100 4 2014700108 CAP SCREW-ZINC, 1/4-20 UNC X 3.00,
 GRADE 5 (@ 6 FT-LBS)
110 4 2014700381 SELF-LOCKING HEX NUT-ZINC, 1/4-20 UNC
120 1 2014701778 ELBOW-1.00 TUBE X 1.00-11.5 NPTF (O-RING)
130 1 2013201249 FORMED TUBE ASSEMBLY-PAR-FLANGED,
 1.00 O.D. (FRESH WATER)
 1 2013201250 FORMED TUBE ASSEMBLY-PAR-FLANGED,
 1.00 O.D., STAINLESS STEEL (SEA WATER)
140 3 5536215800 CAP SCREW-3/8-16 UNC X 0.75, 
 GRADE 5 (@ 23 FT-LBS)
150 3 5531068600 SELF-LOCKING HEX NUT-ZINC, 3/8-16 UNC
160 1 2013305145 CLAMP SPACER
 - QSI 245i/300i 85
Dryer (optional) - 2011014313
86  - QSI 245i/300i
Dryer (optional) - 2011014313
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2013304187 GROMMET,RUBBER,1.00ID,1.38GD
20 1 2013304186 GROMMET,RUBBER,0.38ID,0.63GD
30 1 2014701305 FIT P,CPLG,BRASS,025X025BLKHD
40 1 2013800374 DRYER,50HP,20/23V,3PH,60HZ
50 12 2010356474 SCREW,TAP,CS,WASH,ZN.25NCX0.50
60 3 2014705167 TUBE-FT,3/8 NYLON 11,BLACK
70 1 2011015109 GR,ELE,DRY,200/230V,QSI-50 HP
80 1 2012102115 KT,DRYER SHELF,QSI-245I/300I
90 8 2010356492 SCREW,CAP,CS,HEX ,ZN,M08 X 25
100 1 2014701665 FIT T,ELBOW,FLLS,038NTX025MPX9
110 8 2014700069 SCREW,CAP,WHIZLOCK,5/16-18X.75
120 10 2014700430 NUT,LOK,.31 NC,SAE 2,NONE
130 1 2013305620 BRACKET,UNION
140 2 2025501345 SCREW,CAP,CS,HEX ,ZN.31NCX1.75
150 1 2014701934 FIT T,CONEC,FLLS,038NTX038MP
160 1 2013305996 TIE,CABLE,SELF LOCK,BLACK,14.5
170 1 2014700828 FIT H,UNION,37DEG,188X188
180 1 2025500973 NUT,LOK,.25 NC,SAE 2,NONE
190 1 2010356493 SCREW,CAP,CS,HEX ,ZN.25NCX1.50
DRYER ELECTRICAL CONTROL (NOT SHOWN) - LOCATED IN THE ELECTRICAL ENCLOSURE:
 1 2014703676 RELAY,SOCKET,15AMP/24VAC,DPDT
 1 2014000805 HOLDER,FUSE,30A,L/IND,CL CC,3P
 1 1089941524 CONTACTOR,120V
 1 1089941547 CONTACTOR,120V (50 HP, 380/415/460/575 VOLT &
 60 HP, 200/230/460/575 VOLT)
 3 2014702982 FUSE,600/12.0TD,0.41DIAX1.50LG
 3 1089916851 FUSE,600/7.50TD,0.41DIAX1.50LG
 3 2014703052 FUSE,600/5.60TD,0.41DIAX1.50LG
 3 2014703055 FUSE,600/20.0TD,0.41DIAX1.50LG
 3 2014703054 FUSE,600/9.00TD,0.41DIAX1.50LG

 - QSI 245i/300i 87
Dryer (optional) - 2011014314
88  - QSI 245i/300i
Dryer (optional) - 2011014314
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2013304187 GROMMET,RUBBER,1.00ID,1.38GD
20 1 2013304186 GROMMET,RUBBER,0.38ID,0.63GD
30 1 2014701305 FIT P,CPLG,BRASS,025X025BLKHD
40 1 2013800374 DRYER,50HP,20/23V,3PH,60HZ
50 12 2010356474 SCREW,TAP,CS,WASH,ZN.25NCX0.50
60 3 2014705167 TUBE-FT,3/8 NYLON 11,BLACK
70 1 2011015109 GR,ELE,DRY,200/230V,QSI-50 HP
80 1 2012102115 KT,DRYER SHELF,QSI-245I/300I
90 8 2010356492 SCREW,CAP,CS,HEX ,ZN,M08 X 25
100 1 2014701665 FIT T,ELBOW,FLLS,038NTX025MPX9
110 8 2014700069 SCREW,CAP,WHIZLOCK,5/16-18X.75
120 10 2014700430 NUT,LOK,.31 NC,SAE 2,NONE
130 1 2013305620 BRACKET,UNION
140 2 2025501345 SCREW,CAP,CS,HEX ,ZN.31NCX1.75
150 1 2014701934 FIT T,CONEC,FLLS,038NTX038MP
160 1 2013305996 TIE,CABLE,SELF LOCK,BLACK,14.5
170 1 2014700828 FIT H,UNION,37DEG,188X188
180 1 2025500973 NUT,LOK,.25 NC,SAE 2,NONE
190 1 2010356493 SCREW,CAP,CS,HEX ,ZN.25NCX1.50
DRYER ELECTRICAL CONTROL (NOT SHOWN) - LOCATED IN THE ELECTRICAL ENCLOSURE:
 1 2014703676 RELAY,SOCKET,15AMP/24VAC,DPDT
 1 2014000805 HOLDER,FUSE,30A,L/IND,CL CC,3P
 1 1089941524 CONTACTOR,120V
 1 1089941547 CONTACTOR,120V (50 HP, 380/415/460/575 VOLT &
 60 HP, 200/230/460/575 VOLT)
 3 2014702982 FUSE,600/12.0TD,0.41DIAX1.50LG
 3 1089916851 FUSE,600/7.50TD,0.41DIAX1.50LG
 3 2014703052 FUSE,600/5.60TD,0.41DIAX1.50LG
 3 2014703055 FUSE,600/20.0TD,0.41DIAX1.50LG
 3 2014703054 FUSE,600/9.00TD,0.41DIAX1.50LG

 - QSI 245i/300i 89
Dryer (optional) - 2011014315
90  - QSI 245i/300i
Dryer (optional) - 2011014315
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 8 2014700069 SCREW,CAP,WHIZLOCK,5/16-18X.75
20 1 2012102115 KT,DRYER SHELF,QSI-245I/300I
30 1 2013800357 DRYER,40HP,575V,3PH,60HZ
40 1 2014701305 FIT P,CPLG,BRASS,025X025BLKHD
50 1 2013304187 GROMMET,RUBBER,1.00ID,1.38GD
60 1 2025500973 NUT,LOK,.25 NC,SAE 2,NONE
70 1 2013304186 GROMMET,RUBBER,0.38ID,0.63GD
80 10 2014700430 NUT,LOK,.31 NC,SAE 2,NONE
90 3 2014705167 TUBE-FT,3/8 NYLON 11,BLACK
100 8 2010356492 SCREW,CAP,CS,HEX ,ZN,M08 X 25
110 1 2014700828 FIT H,UNION,37DEG,188X188
120 12 2010356474 SCREW,TAP,CS,WASH,ZN.25NCX0.50
130 1 2010356493 SCREW,CAP,CS,HEX ,ZN.25NCX1.50
140 1 2014701934 FIT T,CONEC,FLLS,038NTX038MP
150 2 2025501345 SCREW,CAP,CS,HEX ,ZN.31NCX1.75
160 1 2013305620 BRACKET,UNION
170 1 2013305996 TIE,CABLE,SELF LOCK,BLACK,14.5
180 1 2014701665 FIT T,ELBOW,FLLS,038NTX025MPX9
190 1 2011015112 GR,ELE,DRY, 575 V,QSI-50 HP
DRYER ELECTRICAL CONTROL (NOT SHOWN) - LOCATED IN THE ELECTRICAL ENCLOSURE:
 1 2014703676 RELAY,SOCKET,15AMP/24VAC,DPDT
 1 2014000805 HOLDER,FUSE,30A,L/IND,CL CC,3P
 1 1089941524 CONTACTOR,120V
 1 1089941547 CONTACTOR,120V (50 HP, 380/415/460/575 VOLT &
 60 HP, 200/230/460/575 VOLT)
 3 2014702982 FUSE,600/12.0TD,0.41DIAX1.50LG
 3 1089916851 FUSE,600/7.50TD,0.41DIAX1.50LG
 3 2014703052 FUSE,600/5.60TD,0.41DIAX1.50LG
 3 2014703055 FUSE,600/20.0TD,0.41DIAX1.50LG
 3 2014703054 FUSE,600/9.00TD,0.41DIAX1.50LG

 - QSI 245i/300i 91
Dryer (optional) - 2011014316
92  - QSI 245i/300i
Dryer (optional) - 2011014316
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2010356493 SCREW,CAP,CS,HEX ,ZN.25NCX1.50
20 8 2014700069 SCREW,CAP,WHIZLOCK,5/16-18X.75
30 3 2014705167 TUBE-FT,3/8 NYLON 11,BLACK
40 1 2014701305 FIT P,CPLG,BRASS,025X025BLKHD
50 1 2025500973 NUT,LOK,.25 NC,SAE 2,NONE
60 1 2013800375 DRYER,50HP,38/41V,3PH,50HZ
70 8 2010356492 SCREW,CAP,CS,HEX ,ZN,M08 X 25
80 1 2013304186 GROMMET,RUBBER,0.38ID,0.63GD
90 1 2013305996 TIE,CABLE,SELF LOCK,BLACK,14.5
100 2 2025501345 SCREW,CAP,CS,HEX ,ZN.31NCX1.75
110 12 2010356474 SCREW,TAP,CS,WASH,ZN.25NCX0.50
120 1 2013305620 BRACKET,UNION
130 1 2014701934 FIT T,CONEC,FLLS,038NTX038MP
140 10 2014700430 NUT,LOK,.31 NC,SAE 2,NONE
150 1 2014700828 FIT H,UNION,37DEG,188X188
160 1 2014701665 FIT T,ELBOW,FLLS,038NTX025MPX9
170 1 2011015110 GR,ELE,DRY,380/415V,QSI-50 HP
180 1 2012102115 KT,DRYER SHELF,QSI-245I/300I
190 1 2013304187 GROMMET,RUBBER,1.00ID,1.38GD
DRYER ELECTRICAL CONTROL (NOT SHOWN) - LOCATED IN THE ELECTRICAL ENCLOSURE:
 1 2014703676 RELAY,SOCKET,15AMP/24VAC,DPDT
 1 2014000805 HOLDER,FUSE,30A,L/IND,CL CC,3P
 1 1089941524 CONTACTOR,120V
 1 1089941547 CONTACTOR,120V (50 HP, 380/415/460/575 VOLT &
 60 HP, 200/230/460/575 VOLT)
 3 2014702982 FUSE,600/12.0TD,0.41DIAX1.50LG
 3 1089916851 FUSE,600/7.50TD,0.41DIAX1.50LG
 3 2014703052 FUSE,600/5.60TD,0.41DIAX1.50LG
 3 2014703055 FUSE,600/20.0TD,0.41DIAX1.50LG
 3 2014703054 FUSE,600/9.00TD,0.41DIAX1.50LG

 - QSI 245i/300i 93
Dryer (optional) - 2011014317
94  - QSI 245i/300i
Dryer (optional) - 2011014317
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2012102115 KT,DRYER SHELF,QSI-245I/300I
20 12 2010356474 SCREW,TAP,CS,WASH,ZN.25NCX0.50
30 1 2013305996 TIE,CABLE,SELF LOCK,BLACK,14.5
40 1 2013800383 DRYER,60HP,20/23V,3PH,60HZ
50 8 2014700069 SCREW,CAP,WHIZLOCK,5/16-18X.75
60 1 2013304187 GROMMET,RUBBER,1.00ID,1.38GD
70 1 2013304186 GROMMET,RUBBER,0.38ID,0.63GD
80 1 2013305620 BRACKET,UNION
90 3 2014705167 TUBE-FT,3/8 NYLON 11,BLACK
100 1 2011015113 GR,ELE,DRY,200/230V,QSI-60 HP
110 2 2025501345 SCREW,CAP,CS,HEX ,ZN.31NCX1.75
120 1 2014701305 FIT P,CPLG,BRASS,025X025BLKHD
130 1 2025500973 NUT,LOK,.25 NC,SAE 2,NONE
140 1 2010356493 SCREW,CAP,CS,HEX ,ZN.25NCX1.50
150 1 2014700828 FIT H,UNION,37DEG,188X188
160 8 2010356492 SCREW,CAP,CS,HEX ,ZN,M08 X 25
170 1 2014701665 FIT T,ELBOW,FLLS,038NTX025MPX9
180 1 2014701934 FIT T,CONEC,FLLS,038NTX038MP
190 10 2014700430 NUT,LOK,.31 NC,SAE 2,NONE
DRYER ELECTRICAL CONTROL (NOT SHOWN) - LOCATED IN THE ELECTRICAL ENCLOSURE:
 1 2014703676 RELAY,SOCKET,15AMP/24VAC,DPDT
 1 2014000805 HOLDER,FUSE,30A,L/IND,CL CC,3P
 1 1089941524 CONTACTOR,120V
 1 1089941547 CONTACTOR,120V (50 HP, 380/415/460/575 VOLT &
 60 HP, 200/230/460/575 VOLT)
 3 2014702982 FUSE,600/12.0TD,0.41DIAX1.50LG
 3 1089916851 FUSE,600/7.50TD,0.41DIAX1.50LG
 3 2014703052 FUSE,600/5.60TD,0.41DIAX1.50LG
 3 2014703055 FUSE,600/20.0TD,0.41DIAX1.50LG
 3 2014703054 FUSE,600/9.00TD,0.41DIAX1.50LG

 - QSI 245i/300i 95
Dryer (optional) - 2011014318
96  - QSI 245i/300i
Dryer (optional) - 2011014318
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2014701305 FIT P,CPLG,BRASS,025X025BLKHD
20 3 2014705167 TUBE-FT,3/8 NYLON 11,BLACK
30 1 2011015115 GR,ELE,DRY, 460 V,QSI-60 HP
40 1 2010356493 SCREW,CAP,CS,HEX ,ZN.25NCX1.50
50 1 2025500973 NUT,LOK,.25 NC,SAE 2,NONE
60 1 2014701934 FIT T,CONEC,FLLS,038NTX038MP
70 2 2025501345 SCREW,CAP,CS,HEX ,ZN.31NCX1.75
80 1 2013800385 DRYER,60HP,460V,3PH,60HZ
90 8 2010356492 SCREW,CAP,CS,HEX ,ZN,M08 X 25
100 12 2010356474 SCREW,TAP,CS,WASH,ZN.25NCX0.50
110 1 2013305620 BRACKET,UNION
120 1 2013304186 GROMMET,RUBBER,0.38ID,0.63GD
130 10 2014700430 NUT,LOK,.31 NC,SAE 2,NONE
140 1 2012102115 KT,DRYER SHELF,QSI-245I/300I
150 1 2013305996 TIE,CABLE,SELF LOCK,BLACK,14.5
160 1 2014700828 FIT H,UNION,37DEG,188X188
170 8 2014700069 SCREW,CAP,WHIZLOCK,5/16-18X.75
180 1 2014701665 FIT T,ELBOW,FLLS,038NTX025MPX9
190 1 2013304187 GROMMET,RUBBER,1.00ID,1.38GD
DRYER ELECTRICAL CONTROL (NOT SHOWN) - LOCATED IN THE ELECTRICAL ENCLOSURE:
 1 2014703676 RELAY,SOCKET,15AMP/24VAC,DPDT
 1 2014000805 HOLDER,FUSE,30A,L/IND,CL CC,3P
 1 1089941524 CONTACTOR,120V
 1 1089941547 CONTACTOR,120V (50 HP, 380/415/460/575 VOLT &
 60 HP, 200/230/460/575 VOLT)
 3 2014702982 FUSE,600/12.0TD,0.41DIAX1.50LG
 3 1089916851 FUSE,600/7.50TD,0.41DIAX1.50LG
 3 2014703052 FUSE,600/5.60TD,0.41DIAX1.50LG
 3 2014703055 FUSE,600/20.0TD,0.41DIAX1.50LG
 3 2014703054 FUSE,600/9.00TD,0.41DIAX1.50LG

 - QSI 245i/300i 97
Dryer (optional) - 2011014319
98  - QSI 245i/300i
Dryer (optional) - 2011014319
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2013304187 GROMMET,RUBBER,1.00ID,1.38GD
20 12 2010356474 SCREW,TAP,CS,WASH,ZN.25NCX0.50
30 1 2010356493 SCREW,CAP,CS,HEX ,ZN.25NCX1.50
40 3 2014705167 TUBE-FT,3/8 NYLON 11,BLACK
50 1 2013305620 BRACKET,UNION
60 1 2012102115 KT,DRYER SHELF,QSI-245I/300I
70 1 2013800386 DRYER,60HP,575V,3PH,60HZ
80 1 2014701665 FIT T,ELBOW,FLLS,038NTX025MPX9
90 1 2011015116 GR,ELE,DRY, 575 V,QSI-60 HP
100 1 2013305996 TIE,CABLE,SELF LOCK,BLACK,14.5
110 1 2025500973 NUT,LOK,.25 NC,SAE 2,NONE
120 1 2014701305 FIT P,CPLG,BRASS,025X025BLKHD
130 8 2014700069 SCREW,CAP,WHIZLOCK,5/16-18X.75
140 2 2025501345 SCREW,CAP,CS,HEX ,ZN.31NCX1.75
150 1 2014700828 FIT H,UNION,37DEG,188X188
160 1 2013304186 GROMMET,RUBBER,0.38ID,0.63GD
170 1 2014701934 FIT T,CONEC,FLLS,038NTX038MP
180 10 2014700430 NUT,LOK,.31 NC,SAE 2,NONE
190 8 2010356492 SCREW,CAP,CS,HEX ,ZN,M08 X 25
DRYER ELECTRICAL CONTROL (NOT SHOWN) - LOCATED IN THE ELECTRICAL ENCLOSURE:
 1 2014703676 RELAY,SOCKET,15AMP/24VAC,DPDT
 1 2014000805 HOLDER,FUSE,30A,L/IND,CL CC,3P
 1 1089941524 CONTACTOR,120V
 1 1089941547 CONTACTOR,120V (50 HP, 380/415/460/575 VOLT &
 60 HP, 200/230/460/575 VOLT)
 3 2014702982 FUSE,600/12.0TD,0.41DIAX1.50LG
 3 1089916851 FUSE,600/7.50TD,0.41DIAX1.50LG
 3 2014703052 FUSE,600/5.60TD,0.41DIAX1.50LG
 3 2014703055 FUSE,600/20.0TD,0.41DIAX1.50LG
 3 2014703054 FUSE,600/9.00TD,0.41DIAX1.50LG

 - QSI 245i/300i 99
Dryer (optional) - 2011014320
100  - QSI 245i/300i
Dryer (optional) - 2011014320
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2013304186 GROMMET,RUBBER,0.38ID,0.63GD
20 1 2013305620 BRACKET,UNION
30 1 2013305996 TIE,CABLE,SELF LOCK,BLACK,14.5
40 3 2014705167 TUBE-FT,3/8 NYLON 11,BLACK
50 1 2013800384 DRYER,60HP,38/41V,3PH,50HZ
60 10 2014700430 NUT,LOK,.31 NC,SAE 2,NONE
70 1 2012102115 KT,DRYER SHELF,QSI-245I/300I
80 8 2010356492 SCREW,CAP,CS,HEX ,ZN,M08 X 25
90 1 2014701305 FIT P,CPLG,BRASS,025X025BLKHD
100 1 2014701934 FIT T,CONEC,FLLS,038NTX038MP
110 1 2014701665 FIT T,ELBOW,FLLS,038NTX025MPX9
120 12 2010356474 SCREW,TAP,CS,WASH,ZN.25NCX0.50
130 1 2010356493 SCREW,CAP,CS,HEX ,ZN.25NCX1.50
140 8 2014700069 SCREW,CAP,WHIZLOCK,5/16-18X.75
150 1 2025500973 NUT,LOK,.25 NC,SAE 2,NONE
160 1 2013304187 GROMMET,RUBBER,1.00ID,1.38GD
170 1 2014700828 FIT H,UNION,37DEG,188X188
180 1 2011015114 GR,ELE,DRY,380/415V,QSI-60 HP
190 2 2025501345 SCREW,CAP,CS,HEX ,ZN.31NCX1.75
DRYER ELECTRICAL CONTROL (NOT SHOWN) - LOCATED IN THE ELECTRICAL ENCLOSURE:
 1 2014703676 RELAY,SOCKET,15AMP/24VAC,DPDT
 1 2014000805 HOLDER,FUSE,30A,L/IND,CL CC,3P
 1 1089941524 CONTACTOR,120V
 1 1089941547 CONTACTOR,120V (50 HP, 380/415/460/575 VOLT &
 60 HP, 200/230/460/575 VOLT)
 3 2014702982 FUSE,600/12.0TD,0.41DIAX1.50LG
 3 1089916851 FUSE,600/7.50TD,0.41DIAX1.50LG
 3 2014703052 FUSE,600/5.60TD,0.41DIAX1.50LG
 3 2014703055 FUSE,600/20.0TD,0.41DIAX1.50LG
 3 2014703054 FUSE,600/9.00TD,0.41DIAX1.50LG

 - QSI 245i/300i 101
Cabinet (air-cooled) - 2011015007
102  - QSI 245i/300i
Cabinet (air-cooled) - 2011015007
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2011015015 KT,CAB,QSI-245/300I,AC,L/DRY
20 24 2013305609 RIVET,CLOSED-END,.157DX.414L
30 2013305820 ADHESIVE,INSTANT,1 OZ TUBE
40 1 2011015013 KT,CAB,QSI-245I/300I,CORE
50 40 2010356474 SCREW,TAP,CS,WASH,ZN.25NCX0.50
60 24 2013305799 TRIM,DOOR,QSI-I/QGV-I
70 18 2014700047 SCREW,LOK,CS,HEX,ZN,M08 X 20
80 8 2013304349 TRIM-FT,FLEXIBLE,.438D
90 12 2013305549 SUPPORT,DOOR
100 3 2014100771 DECAL,Q/QUINCY,15.00X13.66,WH
110 10 2013303178 LATCH,1/4 TURN,55MM
 

 - QSI 245i/300i 103
Cabinet (air-cooled) - 2011015008
104  - QSI 245i/300i
Cabinet (air-cooled) - 2011015008
ITEM NO. QTY. PART NUMBER DESCRIPTION
10 1 2011015013 KT,CAB,QSI-245I/300I,CORE
20 24 2013305609 RIVET,CLOSED-END,.157DX.414L
30 40 2010356474 SCREW,TAP,CS,WASH,ZN.25NCX0.50
40 10 2013303178 LATCH,1/4 TURN,55MM
50 8 2013304349 TRIM-FT,FLEXIBLE,.438D
60 18 2014700047 SCREW,LOK,CS,HEX,ZN,M08 X 20
70 1 2011015017 KT,CAB,QSI-245/300I,AC,W/DRY
80 12 2013305549 SUPPORT,DOOR
90 3 2014100771 DECAL,Q/QUINCY,15.00X13.66,WH
 
FILME Compressor
106  - QSI 245i/300i
Cabinet (water-cooled) - 2011015009
ITEM NO. QTY. PART NUMBER DESCRIPTION
1 2 2013305550 CABINET POST PANEL
2 2 2013305551 DOOR PANEL
3 1 2013305563 ROOF SUPPORT PANEL
4 2 2013305553 ROOF SUPPORT PANEL
5 1 2013305554 CENTER ROOF SUPPORT PANEL
6 1 2013305566 CABINET POST PANEL
7 4 2013305556 CORNER POST PANEL
8 1 2013305557 ROOF SUPPORT PANEL
9 1 2013305558 DOOR PANEL
10 1 2013305561 COVER PANEL
11 1 2013305562 DOOR PANEL
12 1 2013305565 TOP PANEL (LESS DRYER OR WITH DRYER, TEFC)
 1 2013305570 TOP PANEL (WITH DRYER, ODP)
13 1 2013305551 DOOR PANEL
14 1 2013305564 VENTED DOOR PANEL (LESS DRYER)
 1 2013305559 VENTED DOOR PANEL (WITH DRYER)
15 1 2013305570 TOP PANEL (LESS DRYER, ODP)
 1 2013305560 TOP PANEL (WITH DRYER, ODP)
 1 2013305565 TOP PANEL (LESS DRYER, TEFC)
 1 2013305560 TOP PANEL (WITH DRYER, TEFC)
16 18 2014700047 CAP SCREW-ZINC, 8 MM X 20 MM
17 40 2010356474 HEX HEAD SCREW-ZINC, 1/4-20 UNC X 0.50
18 8.0 FT 2013304349 PAN EL TRIM
19 12 2013305549 DOOR SUPPORT
20 24 2013305609 RIVET
21 10 2013303178 QUARTER TURN DOOR LATCH
22 3 2014100771 DECAL-Q/QUINCY, WHITE (15 INCH)
23* 1 2013600231 FAN GUARD
24* 1 2013600280 FAN -6 BLADE, 15.0 O.D.
25* 1 2013600245 FAN GUARD
26* 8 2025501527 FLAT WASHER-0.31
27* 4 2025500920 SELF-LOCKING HEX NUT-ZINC, 5/16-18 UNC
28* 4 2025501349 CAP SCREW-ZINC, 3/8-16 UNC X 1.00,
 GRAD E 5 (@ 23 FT-LBS)
29* 4 2025501528 FLAT WASHER-0.38
30* 4 2025501568 LOCKWASHER-ZINC, 0.38
31* 4 2025501343 CAP SCREW-ZINC, 5/16-18 UNC X 1.25,
 GRAD E 5 (@ 13 FT-LBS)
 * REFERENCE DRAWING NOTE.

 - QSI 245i/300i 107
Decals - 2011004155 - 220i/245i/250i/300i
Quincy Compressor
108  - QSI 245i/300i
Decals - 2011004155 - 220i/245i/250i/300i
ITEM NO. QTY. PART NUMBER DESCRIPTION
1 1 1627456231 SAFETY DECAL SHEET
2 1 2014100687 DECAL-QSI-220I
 1 2014100689 DECAL-QSI-245I
 1 2014100691 DECAL-QSI-250I
 1 2014100693 DECAL-QSI-300I
3 1 2014100771 DECAL-Q/QUINCY, WHITE (15 INCH)
4 1 2014100526 FLUID LEVEL DECAL
5 1 1627409012 CAUTION TAG-JOG MOTOR
6 1 1627409076 TAG -FLUID TYPE SHIPPED WITH UNIT
7 1 2010356485 GENUINE QUINCY COMPONENTS LABEL
8 1 1627456001 P LASTIC ENVELOPE
9 1 1627409013 TAG -PLUGS REMOVED... 
 (USED ON W/C ONLY, NOT SHOWN)
10 1 2024102600 DECAL-CONTROL PANEL, UL LISTED
11 1 2014100783 DECAL-ROYAL BLUE WARRANTY
12 1 1627409049 DECAL-THIS MACHINE PROTECTED WITH QUINSYN PG™
 1 1627409050 DECAL-THIS MACHINE PROTECTED WITH QUINSYN PLUS
 1 2014100428 DECAL-THIS MACHINE PROTECTED WITH QUINSYN XP®
 1 1627409006 DECAL-THIS MACHINE PROTECTED WITH QUINSYN-F®
UPDATED PER PRODUCTION CHANGES (08/06/07).
 - QSI 245i/300i 109
Control Schematic (standard PLC control)
147245-1
110  - QSI 245i/300i
Control Schematic (electronic control)
146572-1
 - QSI 245i/300i 111
Control Schematic (Power$ync control)
146573-1
112  - QSI 245i/300i
Electrical Control Diagram (PLC, auto dual, full voltage)
WP2060A